LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 214 (Instrument Panel System Displays, Gauges And Console) >> Repair Instructions >> Instrument Panel (I/P) Carrier Replacement (Chevrolet) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
    CAUTION: Refer to Battery Disconnect Caution in Cautions and Notices.
  1. Disconnect the negative battery cable. Refer to Battery Negative Cable Disconnect/Connect Procedure in Engine Electrical.
    2. CAUTION: Refer to SIR Caution in Cautions and Notices.
  2. Disable the SIR system. Refer to SIR Disabling and Enabling Zone 3 and to SIR Disabling and Enabling Zone 5 in SIR.
  3. Remove the instrument panel (I/P) trim pad. Refer to Trim Pad Replacement - Instrument Panel (I/P) (Chevrolet)  or Trim Pad Replacement - Instrument Panel (I/P) (Pontiac) .
  4. Remove the I/P cluster. Refer to Instrument Panel Cluster (IPC) Replacement (Chevrolet)  or Instrument Panel Cluster (IPC) Replacement (Pontiac) .
  5. Remove the I/P mounted SIR module. Refer to Inflatable Restraint Instrument Panel Module Replacement in SIR.
  6. Remove the screw (4) from the HVAC temperature control cable.
    Fig 1: Identifying HVAC Temperature Control Cable Screw (Chevrolet)
    GM1215614Courtesy of GENERAL MOTORS CORP.
  7. Remove the control cable end (3) from the door lever (2).
  8. Remove the HVAC control assembly from the I/P carrier. Leave the harness connected to the HVAC control and position aside. Refer to HVAC Control Assembly Replacement (Chevrolet) or HVAC Control Assembly Replacement (Pontiac) in HVAC Systems-Manual.
  9. Remove the radio from the I/P carrier. Refer to Radio Replacement in Entertainment.
  10. Remove the air distribution duct. Refer to Air Distributor Duct Replacement (Chevrolet) or Air Distributor Duct Replacement (Pontiac) in HVAC Systems - Automatic.
  11. Remove the steering wheel. Refer to Steering Wheel Replacement in Steering Wheel and Column.
  12. Remove the tilt lever. Refer to Tilt Lever Replacement in Steering Wheel and Column.
  13. Remove the washer switch. Refer to Wipers/Washer Switch Replacement in Wipers/Washer Systems.
  14. Remove the screws (2) from the I/P carrier (3).
    Fig 2: Removing I/P Carrier Screws (Chevrolet)
    GM288324Courtesy of GENERAL MOTORS CORP.
  15. Remove the nuts (4) from the I/P carrier (3).
  16. Remove the I/P carrier (3) from the lower tie bar (1).
  17. Remove the I/P carrier (3) from the vehicle.
scientia non olet · About LEMON Manuals