LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 214 (Instrument Panel System Displays, Gauges And Console) >> Repair Instructions >> Door Replacement - Instrument Panel (I/P) Compartment >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the I/P compartment door lock cylinder. Refer to Lock Cylinder Replacement - Instrument Panel (I/P) Compartment Door .
  2. Install the I/P compartment door latch. Refer to Latch Replacement - Instrument Panel (I/P) Compartment .
  3. Position the I/P compartment door (1) to the inner reinforcement cover (4).
  4. Install the reinforcement cover (4) to the I/P compartment door (1).
    5. NOTE: Refer to Fastener Notice in Cautions and Notices.
    Fig 1: Installing Inner I/P Reinforcement Cover Screws
    GM834336Courtesy of GENERAL MOTORS CORP.
  5. Install the I/P compartment door screws (2).

    Tighten:  Tighten the screws to 2.3 N.m (20 lb in).

  6. Position the I/P compartment door hinge to the I/P carrier.
  7. Install the screws to the I/P compartment door hinge.

    Tighten:  Tighten the screws to 2.3 N.m (20 lb in).

    8. Fig 2: Installing I/P Compartment Door Stop Strap
    GM740266Courtesy of GENERAL MOTORS CORP.
  8. Install the I/P compartment door stop strap into the opening in the I/P carrier.
  9. Close the I/P compartment door.
scientia non olet · About LEMON Manuals