LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 212 (Engine Controls - 2.2L (L61) Introduction) >> Repair Instructions >> Filler Tube Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the fuel filler pipe.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  2. Install the fuel filler pipe attaching screw to the under body.
    Fig 1: Identifying Fuel Filler Pipe Attaching Screw
    GM783458Courtesy of GENERAL MOTORS CORP.

    Tighten:  Tighten the fuel filler pipe attaching screw to 10 N.m (89 lb in).

  3. Install the fuel filler hose.
    Fig 2: View of Fuel Filler Hose
    GM783454Courtesy of GENERAL MOTORS CORP.
  4. Position the fuel filler hose clamp at the fuel tank and fuel fill tube.

    Tighten:  Tighten the fuel tank filler hose clamps to 3 N.m (27 lb in).

  5. Lower the vehicle.
  6. Install the fuel filler pipe retainers to the fuel filler pipe access panel.
    Fig 3: Identifying Fuel Filler Pipe Retainers
    GM783460Courtesy of GENERAL MOTORS CORP.
  7. Install the fuel filler cap.
scientia non olet · About LEMON Manuals