LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 212 (Engine Controls - 2.2L (L61) Introduction) >> Repair Instructions >> Air Cleaner Intake Duct Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the resonator assembly through the wheel house opening.
    NOTE: Refer to FASTENER NOTICE in Cautions and Notices.
  2. Install the resonator rear push-in retainer and the upper attaching bolt (5).

    Tighten:  Tighten the bolt to 7 N.m (61 lb in).

    Fig 1: View Of Air Cleaner Intake Duct
    GM13220Courtesy of GENERAL MOTORS CORP.
  3. Install the front air cleaner intake duct (3) through the headlamp assembly opening.
  4. Install the lower push-in retainer (4) to the front air cleaner intake duct.
  5. Install the left front wheel house panel. Refer to Front Fender Liner Replacement in Body Front End.
  6. Install the left front tire and wheel. Refer to Tire and Wheel Removal and Installation in Tires and Wheels.
  7. Lower the vehicle.
  8. Install the upper push-in retainer (1) to the front air cleaner intake duct.
  9. Install the headlamp assembly. Refer to Headlamp Assembly or Headlamp Bulb Replacement (Pontiac) in Lighting Systems.
  10. Install the air cleaner outlet splash shield.
scientia non olet · About LEMON Manuals