LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 210 (Supplemental Inflatable Restraint System) >> Repair Instructions >> SIR Disabling and Enabling Zone 5 >> Disabling Procedure

Disabling Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Turn the steering wheel so that the vehicle's wheels are pointing straight ahead.
  2. Turn the ignition switch to the OFF position.
  3. Remove the key from the ignition switch.
  4. Remove the LH I/P outer trim cover. Refer to Instrument Panel (I/P) Outer Trim Cover Replacement (Chevrolet) or Instrument Panel (I/P) Outer Trim Cover Replacement (Pontiac) in Instrument Panel, Gages, and Console.
    IMPORTANT: With the AIR BAG fuse removed and the ignition switch in the RUN position, the AIR BAG warning lamp illuminates. This is a normal operation and does not indicate an SIR system malfunction.
  5. Remove the AIR BAG fuse from the LH I/P wiring harness junction block.
    Fig 1: Locating AIR BAG Fuse
    GM202097Courtesy of GENERAL MOTORS CORP.
  6. Remove the connector position assurance (CPA) from the inflatable restraint I/P module inline connector located under the instrument panel, left of the steering column.
    Fig 2: Identifying Inflatable Restraint I/P Module Inline Connector
    GM202113Courtesy of GENERAL MOTORS CORP.
  7. Disconnect the inflatable restraint I/P module inline connector.
    Fig 3: View Of Inflatable Restraint I/P Module Inline Connector
    GM202118Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals