LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 205 (Door System, Mirror System & Window System) >> Repair Instructions >> Window Channel Replacement - Front Side Rear >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Position the rear run channel (1) in the front door.
  2. Lift up the rear channel to install the top clip.
    3. NOTE: Refer to Fastener Notice in Cautions and Notices.
    Fig 1: Installing Rear Channel Bolt
    GM738933Courtesy of GENERAL MOTORS CORP.
  3. Install the window rear channel bolt (2).

    Tighten:  Tighten the lower window channel bolt 6 N.m (53 lb in).

  4. Install the reveal molding.
  5. Install the front door window. Refer to Window Replacement - Front Door .
  6. Install the front door water deflector. Refer to Water Deflector Replacement - Front Door .
  7. Install the front door trim panel. Refer to Trim Panel Replacement - Side Front Door (Pontiac)  or Trim Panel Replacement - Side Front Door (Chevrolet) .
scientia non olet · About LEMON Manuals