LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 205 (Door System, Mirror System & Window System) >> Repair Instructions >> Trim Panel Replacement - Side Front Door (Pontiac) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the manual window regulator handle from the front door, if equipped. Refer to Window Regulator Handle Replacement - Door .
  2. Remove the power door lock switch, if equipped. Refer to Power Door Lock Switch Replacement .
  3. Remove the upper extension trim panel screw.
    Fig 1: Removing Upper Extension Trim Panel Screw
    GM279004Courtesy of GENERAL MOTORS CORP.
  4. Remove the upper extension trim panel.
  5. Remove the front door trim panel screws (3).
  6. Remove the armrest screws (1).
  7. Starting at the bottom of the door disengage the trim panel retainers using the J 38778  .
  8. Lift up on the trim panel (2) to disengage the inner belt molding from the door flange.
  9. Remove the door trim panel (2) from the inner door panel.
    Fig 2: Removing Front Door Trim Panel Screws
    GM1021355Courtesy of GENERAL MOTORS CORP.
  10. Disconnect the door speaker electrical connector.
scientia non olet · About LEMON Manuals