LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 201 (Wiring Systems - Specifications, Component Views And Connector End Views) >> Repair Instructions >> Underhood Electrical Center or Junction Block Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Open the hood.
  2. Disconnect the negative battery cable from the battery. Refer to Battery Negative Cable Disconnect/Connect Procedure in Engine Electrical.
  3. Remove the air cleaner mounting bracket. Refer to Mounting Bracket Replacement - Air Cleaner in Body Front End.
  4. Remove the push-in retainer (3) from the electrical center.
    Fig 1: Exploded View Of Electrical Center
    GM740821Courtesy of GENERAL MOTORS CORP.
  5. Remove the electrical center from the inner fender.
  6. Turn the electrical center over and remove the bottom cover.
  7. Remove the four plastic wire retainers.
    NOTE: Note the correct routing of the electrical wiring. Failure to reinstall the wiring properly could result in damage to the wiring.
  8. Label and remove the wires.
  9. Turn the electrical center right side up and remove the fuses and relays.
  10. Remove the electrical center from the vehicle.
scientia non olet · About LEMON Manuals