LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 201 (Wiring Systems - Specifications, Component Views And Connector End Views) >> Repair Instructions >> Underhood Electrical Center or Junction Block Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 Pontiac Sunfire and 2004 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Position the electrical center in the vehicle.
  2. Install the fuses and relays.
  3. Turn the electrical center over and install the wires.
  4. Install the four plastic wire retainers.
  5. Install the bottom cover to the electrical center.
  6. Install the electrical center to the inner fender.
  7. Install the push-in retainer (3) to the electrical center.
    Fig 1: Exploded View Of Electrical Center
    GM740821Courtesy of GENERAL MOTORS CORP.
  8. Install the air cleaner mounting bracket. Refer to Mounting Bracket Replacement - Air Cleaner in Body Front End.
  9. Connect the negative battery cable to the battery. Refer to Battery Negative Cable Disconnect/Connect Procedure in Engine Electrical.
  10. Close the hood.
scientia non olet · About LEMON Manuals