LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2001 >> Cavalier LS, 2.2 4 >> Repair and Diagnosis >> External Pages >> Different car >> Section 136 (Engine Mechanical - 2.4L (Unit Repair)) >> Repair Instructions >> Timing Chain Housing - Installation

Timing Chain Housing - Installation

WARNING: This page is about a different car, the 2002 Pontiac Sunfire and 2002 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.

Tool Required: J 36008-A  Camshaft Timing Pins

Important:  Ensure that the alignment pins are in the cylinder block and the timing chain housing, before installing the timing chain housing. The alignment pins ensure proper chain housing and front cover location for correct front oil seal-to-crankshaft alignment.

Important:  Ensure that the timing chain housing to camshaft housing gaskets are properly oriented. If the gaskets are not properly oriented an oil leak will result.

  1. Install the timing chain housing gaskets.
  2. Install the timing chain housing. No sealer is needed.
  3. Install the timing chain housing to the camshaft housing bolts and hand tighten.
  4. Install the timing chain housing to the block fasteners and hand tighten.
  5. Install the chain housing to the oil pan bolts and hand tighten.
    Fig 1: Timing Chain Housing
    G01777881Courtesy of GENERAL MOTORS CORP.
  6. Tighten the bolts
    • Tighten the (M8 X 1.25 X 25) (1) to 26 N.m (19 ft lbs).
    • Tighten the (M10 X 1.25 X 55) (2) to 50 N.m (37 ft lbs).
    • Tighten the (M8 X 1.25 X 25) (3) to 29 N.m (21 ft lbs).
    Fig 2: Identifying Timing Chain Housing Bolts
    G01777882Courtesy of GENERAL MOTORS CORP.
  7. Install the camshaft sprockets. Sprockets are identical and interchangeable.
  8. Clean the old sealer off of the bolt with a wire brush.
  9. Clean the threaded hole in the camshaft with a nylon bristle brush.
  10. Install the camshaft sprocket bolts and washers while holding the sprockets with J 36008-A  . Tighten the bolts to 70 N.m (52 ft lbs).
  11. Fig 3: Camshaft Sprockets
    G01777883Courtesy of GENERAL MOTORS CORP.
  12. Use Adhesive/Sealant Compound GM P/N United States 12345493, GM P/N Canada 10953488 or the equivalent on the camshaft sprocket bolts.