LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2000 >> Astro Van Passenger, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1190 (Engine Mechanical (Repair Instructions 4 Of 5) - 3.6L (Ly7)) >> Repair Instructions (Off-Vehicle Repair Instructions - Part 3) >> Camshaft Intermediate Drive Chain Idler Installation - Right

Camshaft Intermediate Drive Chain Idler Installation - Right

WARNING: This page is about a different car, the 2004 Buick Rendezvous. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Identifying Recessed Hub On Camshaft Intermediate Drive Chain Idler
    GM1306315Courtesy of GENERAL MOTORS CORP.
  1. Ensure that the right camshaft intermediate drive chain idler (1) is being installed. The recessed hub (4) and the smaller sprocket of the right camshaft intermediate drive chain idler is installed outward. The raised hub and the larger sprocket of the right camshaft intermediate drive chain idler is installed towards the block.
    2. Fig 2: View Of Right And Left Camshaft Intermediate Drive Chain Idlers
    GM946212Courtesy of GENERAL MOTORS CORP.
  2. Install the right camshaft intermediate drive chain idler.
    3. NOTE: Refer to Fastener Notice in Cautions and Notices.
  3. Install the camshaft intermediate drive chain idler bolt.

    Tighten:  Tighten the camshaft intermediate drive chain idler bolt to 58 N.m (43 lb ft).

scientia non olet · About LEMON Manuals