Removal Procedure

WARNING: This page is about a different car, the 2022 Cadillac CT4. However, it is still accessible from the selected car via links, so may be relevant.

Drain the cooling system. Refer to Cooling System Draining and Filling (LF4 Static Fill) , or Cooling System Draining and Filling (LF4 GE 47716)
Raise and support the vehicle. Lifting and Jacking the Vehicle
NOTE:
Left side shown, right side similar.

Front Bumper Fascia Bolt- Right Side (1) - Remove [6x]
Front Bumper Fascia Lower Stiffener Bolt- Right Side (2) - Remove
Front Bumper Fascia Air Deflector Bolt- Right Side (3) - Remove [4x]
NOTE:
Left side shown, right side similar.

Front Bumper Fascia Air Deflector Bolt- Right Side (1) - Remove [6x]
Front Bumper Fascia Lower Reinforcement (2) - Remove
NOTE:
Left side shown, right side similar.

Front Bumper Fascia Air Deflector Bolt- Right Side (1) - Remove [4x]
Front Bumper Fascia Air Deflector- Outer (2) - Remove
Remove the right front tire and wheel assembly. Tire and Wheel Removal and Installation
NOTE:
- Left side shown, right side similar.
- Quantity of fasteners may vary based on option content.
- Some components not shown for graphic clarity.
Engine Front Splash Shield Retainer- Right Side (2) - Remove
Engine Front Splash Shield Bolt- Right Side (1) - Remove [4x]
Engine Front Splash Shield (3) - Remove
NOTE:
Left side shown, right side similar.

Front Wheelhouse Liner Bolt- Right Side (1) - Remove [4x]
Front Wheelhouse Liner Retainer- Right Side (2) - Remove
Front Wheelhouse Liner (3) - Reposition
Auxiliary Radiator Duct Retainer- Right Side (1) - Remove [3x]
Auxiliary Radiator Rear Duct- Right Side (1) - Remove
Front Bumper Fascia (1) - Remove - Front Bumper Fascia Removal and Installation (without Blackwing) , or Front Bumper Fascia Removal and Installation (with Blackwing) , or Front Bumper Fascia Removal and Installation (with Blackwing CFV, CFZ)
Auxiliary Radiator Duct Retainer- Right Side (1) - Remove [3x]
Auxiliary Radiator Duct Retainer- Right Side (1) - Remove [2x]
{ If equipped } Forward Range Radar Bracket (2) - Remove
1. Forward Range Radar Bracket Bolt (1) - Remove [3x]
2. Forward Range Radar Bracket (2) - Remove
3. Disconnect the electrical connector.
NOTE:
Left side shown, right side similar.

Auxiliary Radiator Front Inlet Duct Retainer- Left Side and Right Side (1) - Remove [6x]
NOTE:
Left side shown, right side similar.

Auxiliary Radiator Front Inlet Duct- Left Side and Right Side (1) - Reposition [2x]
Transmission Fluid Auxiliary Cooler Bracket Bolt- Left Side and Right Side (2) - Remove [2x]
NOTE:
Left side shown, right side similar.

Horn Bolt (1)- Left Side and Right Side - Remove [2x]
Horn- Left Side and Right Side (2) - Reposition [2x]
Reposition the wiring harness.
Front Bumper Impact Bar Bolt (1) - Remove [8x]
Front Bumper Impact Bar (2) - Remove
Auxiliary Radiator Front Duct- Right Side (1) - Remove
Using an appropriate tool, remove the auxiliary radiator inlet hose retainer (1) from the auxiliary radiator inlet hose connector at the right side charge air cooler.
Remove the auxiliary radiator inlet hose (2) from the right side charge air cooler.
Radiator Outlet Hose Clip (1) - Remove
Using an appropriate tool, remove the radiator outlet hose retainer (3) from the radiator outlet hose connector at the right side charge air cooler.
Remove the radiator outlet hose (2) from the right side charge air cooler.
Charge Air Cooler Bracket Bolt (1) - Remove [3x]
Charge Air Cooler Upper Bracket Nut (2) - Loosen
Remove the right side charge air cooler assembly (1) from the vehicle.
Radiator Upper Insulator (3) - Remove [2x]
Auxiliary Radiator Bracket Nut (2) - Remove [2x]
Auxiliary Radiator Bracket Bolt (1) - Remove [2x]
Charge Air Cooler Bracket- Upper (1) - Remove
Remove the charge air cooler (2) from the charge air cooler bracket (3).