LEMON Manuals: Even more car manuals for everyone
Home >> Cadillac >> 2021 >> CT4 Sport, 4WD >> Repair and Diagnosis >> External Pages >> Different car >> Section 67 (Rear Drive Axle - Repair Instructions) >> Repair Instructions >> Rear Axle Shaft Replacement - Right Side (LF4) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2022 Cadillac CT4. However, it is still accessible from the selected car via links, so may be relevant.
  1. GM5355066

    Rear Axle Shaft Clip (2) - Install NEW

  2. Using the appropriate tool, install the rear axle shaft (1).
  3. GM5896794

    Install the rear wheel drive shaft (1) onto the rear axle shaft.

  4. GM5864760
    NOTE:

    The rear wheel drive shaft universal joint retainer (1) and washers (2) are serviced as a rear wheel drive shaft universal joint retainer kit consisting of 2 bolts and 1 washer.

    If NEW threaded components are being installed, loosen the adhesive using a metal pick or similar tool before proceeding. If threaded components are reused, prepare the threaded components using the following steps:

    1. Remove any loose cured adhesive from the external threads of the components using a lint free cloth.
    2. Thread the cleaned components into the internal mating threads and remove to loosen trapped cured adhesive.
    3. Apply thread locking adhesive to the external threads of the components. Adhesives, Fluids, Lubricants, and Sealers
    4. Apply liquid thread locking adhesive in a strip along half of the length of the external threads, starting at the tip, just prior to installation.
  5. Install 3 NEW rear wheel drive shaft flange washers (2).
    6. CAUTION:

    Refer to Fastener Caution .

    CAUTION:

    Refer to Torque-to-Yield Fastener Caution .

  6. Install and tighten the 6 NEW rear wheel drive shaft universal joint retainers (1) in a crisscross pattern. Fastener Specifications
  7. GM5865329

    Catalytic Converter Gasket (2) - Install NEW

  8. With the aid of an assistant, install the exhaust muffler (1).
  9. GM5865300

    Exhaust Muffler Hanger Bracket Nut (1) - Install and tighten [4x] - Fastener Specifications

  10. GM5865293

    Electrical Connector (1) - Connect

  11. GM5865287

    Electrical Connector (1) - Connect

  12. GM5406632

    Exhaust Muffler (1) @ Exhaust Rear Muffler Insulator-Right Side (2) - Install

  13. Exhaust Muffler (1) @ Exhaust Intermediate Pipe Insulator-Right Side (2) - Install
  14. GM5406578

    Exhaust Muffler (1) @ Exhaust Rear Muffler Insulator-Left Side (2) - Install

  15. Exhaust Muffler (1) @ Exhaust Intermediate Pipe Insulator-Left Side (2) - Install
  16. GM5865271

    Exhaust Pipe Clamp (1) - Tighten [2x]

  17. GM5865265

    Catalytic Converter Nut (1) - Install and tighten [2x] - Fastener Specifications

  18. GM5400756

    Floor Panel Reinforcement (2) - Install

  19. Floor Panel Number 4 Cross Bar Reinforcement Bolt (1) - Install and tighten [6x] - Fastener Specifications
  20. GM5854893

    Underbody Rear Air Deflector- Left Side (5) - Install

  21. Underbody Rear Air Deflector Bolt- Left Side (4) - Install and tighten [2x] - Fastener Specifications
  22. Transmission Fluid Cooler Pipe Bracket Bolt- Left Side (3) - Install and tighten [2x] - Fastener Specifications
  23. Underbody Rear Air Deflector Nut- Left Side (2) - Install and tighten [5x] - Fastener Specifications
  24. Underbody Front Air Deflector Bolt- Left Side (1) - Install and tighten [6x] - Fastener Specifications
  25. GM5839256

    Underbody Rear Air Deflector- Right Side (5) - Install

  26. Underbody Rear Air Deflector Bolt- Right Side (4) - Install and tighten [2x] - Fastener Specifications
  27. Transmission Fluid Cooler Pipe Bracket Bolt- Right Side (3) - Install and tighten [2x] - Fastener Specifications
  28. Underbody Rear Air Deflector Nut- Right Side (2) - Install and tighten [5x] - Fastener Specifications
  29. Underbody Front Air Deflector Bolt- Right Side (1) - Install and tighten [6x] - Fastener Specifications
  30. GM5400642

    Underbody Rear Air Deflector- Right Side (5) - Install

  31. Underbody Rear Air Deflector Nut (3) - Install and tighten [3x] - Fastener Specifications
  32. Underbody Rear Air Deflector Bolt (2) - Install and tighten [3x] - Fastener Specifications
  33. Underbody Rear Air Deflector Nut (4) - Install and tighten [2x] - Fastener Specifications
  34. Rear Wheelhouse Liner Bolt (1) - Install and tighten - Fastener Specifications
  35. GM5471237

    Rear Tire Front Air Deflector- Right Side (1) - Install

  36. Rear Tire Front Air Deflector Bolt (2) - Install and tighten [2x] - Fastener Specifications
  37. GM5400553

    Underbody Rear Air Deflector- Left Side (5) - Install

  38. Underbody Rear Air Deflector Nut (2) - Install and tighten [3x] - Fastener Specifications
  39. Underbody Rear Air Deflector Bolt (3) - Install and tighten [3x] - Fastener Specifications
  40. Underbody Rear Air Deflector Nut (4) - Install and tighten [2x] - Fastener Specifications
  41. Rear Wheelhouse Liner Bolt (1) - Install and tighten - Fastener Specifications
  42. GM5395705

    Rear Tire Front Air Deflector- Left Side (2) - Install

  43. Rear Tire Front Air Deflector Bolt (1) - Install and tighten [2x] - Fastener Specifications
  44. Inspect the exhaust system for leaks.
  45. Remove the support and lower the vehicle.
scientia non olet · About LEMON Manuals