Fastener Specifications (On Vehicle)
WARNING: This page is about a different car, the 2018 Chevrolet Suburban 3500 HD. However, it is still accessible from the selected car via links, so may be relevant.
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal.
|
|---|
| Application |
| Automatic Transmission Control Wiring Harness Clip |
| Automatic Transmission Fluid Pump Gasket |
| Automatic Transmission Fluid Pump Seal |
| Control Valve Body Spacer Plate |
| Control Valve Body Spacer Plate Retainer |
| Control Valve Channel Plate Spacer Plate |
| Manual Shift Shaft Pin |
| Manual Shift Shaft Detent Lever Hub Pin |
| Propeller Shaft Transmission Flange Fluid Seal |
| Wiring Harness Clip |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal.
|
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Input Speed Sensor Wiring Harness Bolt | |
|
4 N.m (35 lb in) |
|
45 Degrees |
| Output Speed Sensor Wiring Harness Bolt | |
|
4 N.m (35 lb in) |
|
45 Degrees |
| Propeller Shaft Transmission Flange Nut | 105 N.m (77 lb ft) |
| Transmission Fluid Baffle Bolts | |
|
4 N.m (35 lb in) |
|
45 Degrees |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal.
|
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Automatic Transmission Fluid Pressure Test Plug | 11 N.m (97 lb in) |
| Automatic Transmission Range Selector Lever | 25 N.m (18 lb ft) |
| Flywheel Inspection Cover/Converter Cover Fasteners | 12 N.m (106 lb in) |
| Manual Shaft Detent Lever Spring Retaining Bolt | 12 N.m (106 lb in) |
| Range Selector Lever Cable Bracket | 22 N.m (16 lb ft) |
| Torque Converter Bolts | 65 N.m (48 lb ft) |
| Transmission Fluid Pan Bolts | 10 N.m (89 lb in) |
| Transmission Heat Shield Fasteners | 17 N.m (13 lb ft) |
| Transmission Mount Bolt-Light Duty | 55 N.m (40 lb ft) |
| Transmission Mount Bolt-Heavy Duty | 107 N.m (79 lb ft) |
| Transmission Range Selector Cable Bracket Bolt | 22 N.m (16 lb ft) |
| Transmission Range Selector Cable Lever Nut | 25 N.m (18 lb ft) |
| Transmission to Engine Bolts | 50 N.m (37 lb ft) |