Fastener Specifications (On Vehicle)
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Front Wheel Drive Shaft Seal - Left |
| Front Wheel Drive Shaft Seal - Right |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Transmission Mount Bolt - Left Side to Transmission | |
|
50 N.m (37 lb ft) |
|
60-75 Degrees |
| Transmission Rear Mount to Cradle Bolts - FWD | |
|
100 N.m (74 lb ft) |
|
120-130 Degrees |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Control Valve Assembly (with TCM and Body) to Case Bolt - M6x1.0x42 | 12 N.m (106 lb in) |
| Control Valve Assembly (with TCM and Body) to Case Bolt - M6x1.0x55 | 12 N.m (106 lb in) |
| Control Valve Assembly (with TCM and Body) to Case Bolt - M6x1.0x65 | 12 N.m (106 lb in) |
| Control Valve Assembly (with TCM and Body) to Case Bolt - M6x1.0x80 | 12 N.m (106 lb in) |
| Control Valve Body Assembly Bolt - M6x1.0x35 | 12 N.m (106 lb in) |
| Control Valve Body Assembly Bolt - M6x1.0x55 | 12 N.m (106 lb in) |
| Control Valve Body Assembly Bolt - M6x1.0x65 | 12 N.m (106 lb in) |
| Control Valve Body Cover Bolt - M6x1.0x30 | 12 N.m (106 lb in) |
| Control Valve Body Cover Bolt - M6x1.0x95 | 12 N.m (106 lb in) |
| Control Valve Body to Case Bolt - M6x1.0x55 | 12 N.m (106 lb in) |
| Fluid Cooler Fitting at Radiator | 38 N.m (28 lb ft) |
| Fluid Cooler Pipe Nut | 22 N.m (17 lb ft) |
| Fluid Level Hole Plug | 12 N.m (106 lb in) |
| Fluid Pressure Test Hole Plug | 12 N.m (106 lb in) |
| Flywheel Cover Bolt | 10 N.m (89 lb in) |
| Input Speed Sensor Bolt | 9 N.m (80 lb in) |
| Manual Shift Position Switch Screw | 3.5 N.m (31 lb in) |
| Output Speed Sensor Bolt | 12 N.m (106 lb in) |
| Torque Converter to Flywheel Bolt | 62 N.m (46 lb ft) |
| Transaxle Front Brace Bolts | 50 N.m (37 lb ft) |
| Transaxle Rear Brace Bolts | 100 N.m (74 lb ft) |
| Transaxle Range Switch Bolt | 20 N.m (15 lb ft) |
| Transaxle Range Switch Lever Nut | 35 N.m (26 lb ft) |
| Transaxle Shift Control Nut | 8 N.m (71 lb in) |
| Transaxle to Engine Bolt | 75 N.m (55 lb ft) |
| Transmission Cooler Pipe Stud - External Torx | 12 N.m (106 lb in) |
| Transmission Front Mount Through Bolt | 100 N.m (74 lb ft) |
| Transmission Front Mount To Transmission Bolts | 62 N.m (46 lb ft) |
| Transmission Mount Bolt - Left Side to Body | 22 N.m (17 lb ft) |
| Transmission Rear Mount Through Bolt | 105 N.m (77 lb ft) |
| Transmission Rear Mount to Cradle Short Bolts - AWD | 100 N.m (74 lb ft) |
| Transmission Rear Mount to Cradle Long Bolt - AWD | 62 N.m (46 lb ft) |
| Transmission Rear Mount to Transmission Through Bolt | 100 N.m (74 lb ft) |