LEMON Manuals: Even more car manuals for everyone
Home >> Cadillac >> 2013 >> Escalade Hybrid, RWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 5 (Engine Controls/Fuel - 5.3L, 6.0L, 6.2L - Repair Instructions) >> Repair Instructions >> Evaporative Emission Canister Replacement (2500 Series) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different variant/trim than selected.
    Fig 1: View Of EVAP Canister Vent Solenoid Retainer
    GM1706538Courtesy of GENERAL MOTORS COMPANY
  1. Connect the EVAP canister vent solenoid line (1) quick connect fitting at the EVAP canister. Refer to Plastic Collar Quick Connect Fitting Service .
    2. Fig 2: View Of Rear Bracket Clip
    GM1372960Courtesy of GENERAL MOTORS COMPANY
  2. Remove the caps from the EVAP lines.
  3. Install the EVAP canister.
  4. Using a flat bladed screwdriver, engage the rear bracket clip.
    5. Fig 3: View Of Front Bracket Clip
    GM1372958Courtesy of GENERAL MOTORS COMPANY
  5. Using a flat bladed screwdriver, engage the front bracket clip.
    6. Fig 4: View Of EVAP Canister Bracket Nuts
    GM1373032Courtesy of GENERAL MOTORS COMPANY
    CAUTION:

    Refer to Fastener Caution .

  6. Tighten the EVAP canister bracket nuts (1).

    Tighten 

    Tighten the nuts to 25 N.m (18 lb ft).

    7. Fig 5: View Of EVAP Canister & Quick Connect Fittings
    GM1372543Courtesy of GENERAL MOTORS COMPANY
  7. Raise the vehicle.
  8. Install the EVAP canister bolt.

    Tighten 

    Tighten the nuts to 25 N.m (18 lb ft).

  9. Connect the rear fuel tank EVAP canister quick connect fittings to the EVAP canister. Refer to Plastic Collar Quick Connect Fitting Service .
    10. Fig 6: View Of EVAP CVS Electrical Connector & CVS Bracket
    GM1224403Courtesy of GENERAL MOTORS COMPANY
  10. Connect the EVAP canister vent solenoid (CVS) electrical connector (1).
  11. Lower the vehicle.
  12. Install the right side, rear bumper step pad. Refer to Rear Bumper Step Outer Pad Replacement (Avalanche, Cadillac EXT) .
scientia non olet · About LEMON Manuals