LEMON Manuals: Even more car manuals for everyone
Home >> Cadillac >> 2004 >> DeVille Base >> Repair and Diagnosis >> Accessories & Equipment >> Gauges & Instrument Panels >> Instrument Panel System Displays, Gauges And Console >> Repair Instructions >> Console Replacement - Front Floor (DTS without UV8) >> Installation Procedure

Installation Procedure

  1. Install the center console to the vehicle.
  2. Connect the center console electrical connectors.
  3. Align the locating pins on the center console to the I/P.
    4. NOTE: Refer to Fastener Notice in Cautions and Notices.
  4. Install the 2 upper console to I/P fasteners (1).

    Tighten:  Tighten the fasteners (1) to 9 N.m (80 lb in).

  5. Install the 2 lower console to I/P fasteners (2).

    Tighten:  Tighten the fasteners (2) to 9 N.m (80 lb in).

  6. Adjust the front seats to the forward position.
  7. Install the 2 rear console to floor fasteners (4).

    Tighten:  Tighten the fasteners (4) to 9 N.m (80 lb in).

  8. Adjust the front seats to the rear position.
  9. Install the 2 front console to floor fasteners (3).

    Tighten:  Tighten the fasteners (3) to 9 N.m (80 lb in).

    10. Fig 1: View Of Console & Floor Fasteners
    GM474659Courtesy of GENERAL MOTORS CORP.
  10. Install the I/P center compartment. Refer to Compartment Replacement - Instrument Panel (I/P) (Base and DHS)  or Compartment Replacement - Instrument Panel (I/P) (DTS) 
  11. Slide the transaxle range selector cable fully into the console until it snaps into place.
  12. Connect the transaxle range selector cable terminal to the shift lever pin.
    13. Fig 2: View Of Transaxle Range Selector Cable Terminal & Shift Lever Pin
    GM627368Courtesy of GENERAL MOTORS CORP.
  13. Install the console center trim plate. Refer to Trim Plate Replacement - Front Floor Console (DTS) .
  14. Install the right knee bolster. Refer to Knee Bolster Replacement - Right .
  15. Install the left knee bolster. Refer to Knee Bolster Replacement - Left (Without UV2)  or Knee Bolster Replacement - Left (UV2) .
  16. Install both the left and the right console trim panels. Refer to Console Trim Panel Replacement - Left (DTS)  and Console Trim Panel Replacement - Right (DTS) .
  17. Enable the SIR system. Refer to SIR Disabling and Enabling Zone 8 in SIR.
scientia non olet · About LEMON Manuals