LEMON Manuals: Even more car manuals for everyone
Home >> Buick >> 2007 >> Lucerne CX >> Repair and Diagnosis >> External Pages >> Different car >> Section 222 (Heating, Ventilation And Air Conditioning) >> Repair Instructions >> Defroster Door Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2006 Pontiac Montana SV6, 2006 Chevrolet Uplander, and 2006 Buick Terraza. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Locating Defroster Door & Components
    GM1548540Courtesy of GENERAL MOTORS CORP.
    IMPORTANT: The defroster door must be closed to allow clearance during defroster duct removal.
  1. Set the HVAC controls in the vent setting to close the defroster door.
  2. Remove the instrument panel (I/P) carrier. Refer to Instrument Panel (I/P) Carrier Replacement in Instrument Panel, Gages and Console.
  3. Remove the defroster cover bolts/screws (1).
  4. Remove the defroster cover (2).
  5. Remove the defrost actuator bolts/screws (4).
  6. Remove the defrost actuator (3).
  7. Remove the defrost actuator door (5).
scientia non olet · About LEMON Manuals