Fuel Tank Draining: Procedure

WARNING: This page is about a different car, the 2006 Pontiac Montana SV6, 2006 Chevrolet Uplander, and 2006 Buick Terraza. However, it is still accessible from the selected car via links, so may be relevant.

CAUTION: Never drain or store fuel in an open container. Always use an approved fuel storage container in order to reduce the chance of fire or explosion.

CAUTION: a dry chemical (Class B) fire extinguisher nearby before performing any on-vehicle service procedures. Failure to follow these precautions may result in personal injury.

Remove the fuel fill cap.
Install the J 42960-2 into the fuel fill pipe in order to hold the door open.

Fig 1: Draining Fuel Tank

Courtesy of GENERAL MOTORS CORP.

IMPORTANT: Lubricate the fuel drain hose with J 36850 or equivalent to aid in hose insertion. Do not use an unapproved lubricant.

Insert the J 45004 into the fuel tank until the hose reaches the bottom of the fuel tank.
Use an hand or air operated pump device in order to drain as much fuel through the fuel fill pipe as possible.