LEMON Manuals: Even more car manuals for everyone
Home >> Buick >> 2004 >> Century Limited >> Repair and Diagnosis >> External Pages >> Different car >> Section 134 (Engine Mechanical - 3.8L) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Water Pump Installation

Water Pump Installation

WARNING: This page is about a different car, the 2004 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the water pump gasket.
    2. Fig 1: Installing Water Pump & Gasket
    GM187022Courtesy of GENERAL MOTORS CORP.
  2. Install the water pump.
    3. NOTE: Refer to Fastener Notice in Cautions and Notices.
  3. Install the water pump bolts.

    Tighten: 

    • Tighten the small water pump bolts to 22 N.m (16 lb ft).
    • Tighten the large water pump bolts to 34 N.m (25 lb ft).

  4. Install the water pump pulley.
  5. Install the water pump pulley bolts.

    Tighten:  Tighten the water pump pulley bolts to 13 N.m (116 lb in).

    6. Fig 2: Water Pump Pulley & Bolts
    GM36596Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals