61 67 045 Removing and installing/replacing spray nozzles for left or right headlight cleaning system

WARNING: This page does not describe the selected car, but rather 16 other vehicles, including the 2006 BMW 330Ci, 2005 BMW 330xi, 2005 BMW 330i, 2005 BMW 330Ci, and 2004 BMW 330xi. However, it is still accessible from the selected car via links, so may be relevant.

NOTE: Drain fluid tank for windshield washer system

Lever out spray nozzle with telescopic nozzle and pull out up to stop.

Hold telescopic nozzle and pull off spray nozzle.

Allow telescopic nozzle to slowly slide back again.

Fig 1: Removing Spray Nozzle

G03125253

Courtesy of BMW OF NORTH AMERICA, INC.

Installation:

Make sure spray nozzle engages correctly on telescopic nozzle.

Fig 2: Installing Spray Nozzle

G03125254

Courtesy of BMW OF NORTH AMERICA, INC.

Installation:

Do not confuse spray nozzles.

Pay attention to R and L markings on underside of spray nozzles.

Fig 3: Identifying R & L Markings On Underside Of Spray Nozzles

G03125255

Courtesy of BMW OF NORTH AMERICA, INC.

Replacement only:

Converting spray nozzle finisher:

Unclip both retaining hooks at bottom.

Fig 4: Unclipping Retaining Hooks

G03125256

Courtesy of BMW OF NORTH AMERICA, INC.

Remove spray nozzle finisher upwards from spray nozzle.

Installation:

Adjust spray nozzles of headlight cleaning system.

Fig 5: Removing Spray Nozzle Finisher Upwards From Spray Nozzle

G03125257

Courtesy of BMW OF NORTH AMERICA, INC.