Remove rear window
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2023 BMW M5, 2022 BMW M5, 2021 BMW M5, 2020 BMW M5, and 2019 BMW M5. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
TECHNICAL INFORMATION
Perform window removal using the "spider".
For additional information see: 51 31... WINDOW GLASS REMOVAL USING "SPIDER" .
Perform window removal using the "spider".
For additional information see: 51 31... WINDOW GLASS REMOVAL USING "SPIDER" .
NOTE:
TECHNICAL INFORMATION
The following procedure forms the basis for these repair instructions and must be observed without fail.
For additional information see: 51 31... GENERAL PROCEDURE FOR DISASSEMBLY/INSTALLATION OF BONDED WINDOW GLASS .
The following procedure forms the basis for these repair instructions and must be observed without fail.
For additional information see: 51 31... GENERAL PROCEDURE FOR DISASSEMBLY/INSTALLATION OF BONDED WINDOW GLASS .
Preliminary work
- Refer to REMOVING THE TRIM PANEL FOR THE REAR LEFT AND RIGHT WATER CHANNEL .
- Refer to REMOVING BOTH C-PILLAR TRIM PANELS .
- Refer to REMOVING TRIM FOR AUXILIARY BRAKE LIGHT .
- Refer to REMOVING AUXILIARY BRAKE LIGHT .
- Unlock plug connection (1) and disconnect.
- Secure cable to rear window with adhesive tape.
- Loosen nut (1).
- Secure cable (2) to the rear window.
- Unlock plug connection (1) and disconnect.
- Secure cable (2) to rear window with adhesive tape.
- Tape off body in area of piercing point with fabric adhesive tape.
- Push the thread (1) through the adhesive bead along the line from the inside.
- Cut out the rear window with spider 2 357 248 .
- Remove the rear window with the aid of the special tool 2 184 377 .
- Remove the adhesive bead on the body using special tool 0 410 436
and clean the adhesive area.