Replacing left or right rear door trim panel (330i xDrive Wagon, 328d xDrive Wagon)
WARNING: This page does not describe the selected car, but rather 11 other vehicles, including the 2019 BMW 340i GT xDrive, 2019 BMW 330i xDrive, 2019 BMW 330i GT xDrive, 2018 BMW 340i GT xDrive, and 2018 BMW 330i xDrive. However, it is still accessible from the selected car via links, so may be relevant.
Necessary preliminary work:
- Remove rear DOOR TRIM PANEL .
Following parts must be fitted on new door trim panel (if necessary as new part):
- DOOR OPENER (always fit new part)
- ARM SUPPORT .
- DOOR HANDLE .
- SPEAKER COVER .
Depending on version:
- ROLLER SUNBLIND .
- FOOTWELL LIGHT .
- DOOR OPENER LED
- Tweeter with holder (described below)
Version with tweeter:
Aperture for tweeter must be sawn out.
IMPORTANT:
Risk of damage!
Saw only through carrier material (2) and not through covering (3).
Cut through covering (3) with knife.
Saw only through carrier material (2) and not through covering (3).
Cut through covering (3) with knife.
Saw out aperture at mark (1) with 50 mm dia. jigsaw.
Fit holder (1) and secure with lock washers (2).
Saw off all pins (3) to dimension (A).
Dimension (A) = 2 mm
Mount tweeter cover from outside.
Install TWEETER .