Removing the housing cover

WARNING: Vehicle may slip off the vehicle hoist if the vehicle hoist is handled incorrectly .
Danger! Immobilization period-threatening injuries!

Observe safety instructions on raising the vehicle using a vehicle hoist.
For additional information see: 00... RAISING THE VEHICLE WITH A VEHICLE LIFT .

WARNING: Car may slip off the vehicle hoist where components are supported .
Danger! Immobilization period-threatening injuries!

Secure the vehicle hoist against lowering and lifting.
Make sure that the vehicle does not lift off the mounting plates on the vehicle lift.

CAUTION: Acid combustions may result from skin contact with oil or inhaling oil vapors .
Risk of acid burns from contact with oil!

Wear safety goggles and hand protection.
Ensure adequate ventilation.

CAUTION: Contact with hazardous substances .
Health impairment .

Note and comply with the Safety Instructions on the containers and the instructions on the manufacturer's safety data sheet.
Conduct all work in appropriate personal protective equipment only.

NOTE: RISK OF DAMAGE
Damage to rear differential .
Failure to comply with the oil specifications can result in serious damage to the rear differential .

After completion of repair work, check the transmission oil level in the rear differential.
Use only the BMW approved final drive transmission oil. See the Fluid Capacities tab for the selected vehicle.

Preliminary work

Refer to REMOVING THE CONNECTING SUPPORT FROM THE TUNNEL .
Refer to REMOVING COMPLETE EXHAUST SYSTEM .
Refer to REMOVING THE COVER OF THE CAMBER CONTROL ARM ON THE LEFT AND RIGHT .
Refer to REMOVING HEAT SHIELD AT REAR .
Refer to RELEASING THE WIRING HARNESS FROM THE M SPORT DIFFERENTIAL .
Refer to DRAWING OFF OIL IN THE REAR DIFFERENTIAL .
Refer to LOWERING REAR DIFFERENTIAL .

Schematic diagram is for example purposes. Some parts may differ in certain details .

Loosen screws (1) .
Take off case cover.

Courtesy of BMW OF NORTH AMERICA, INC.