LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2018 >> M4 2D Convertible, Automatic DCT Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 14 (Air Bag/SRS Component Inspection & Replacement Tables - EUROPEAN) >> Jaguar (1990-04)

Jaguar (1990-04)

WARNING: This page does not describe the selected car, but rather 827 other vehicles, including the 2009 Volkswagen Golf, 2008 Volkswagen Golf, 2007 Volkswagen Golf, 2005 Audi allroad, and 2004 Volvo XC90. However, it is still accessible from the selected car via links, so may be relevant.
WARNING: Accidental air bag deployment is possible. Personal injury may result. Avoid area near steering wheel and instrument panel even if air bags have deployed. Dual-stage air bag modules may be present that could contain an undeployed stage. When disposing of a deployed dual-stage air bag, always treat it as a "live" module. See appropriate AIR BAG RESTRAINT SYSTEM article.
APPLICATION - JAGUAR

Make/Model Year Location Table
S Type 2002-04 D-P2, HI, SI Jaguar-5 
  1999-01 D-P, SI Jaguar-3 
X Type 2004 D-P2, HI, SI, Jaguar-4 
    KI  
  2002-03 D-P2, HI, SI Jaguar-4 
XJ Series 2004 D-P2, HI, SI Jaguar-5 
  1998-03 D-P, SI Jaguar-1 
XJR 1995-97 D-P Jaguar-2 
XJS 1994-96 D-P Jaguar-2 
  1990-93 DS Jaguar-2 
XJ6 1994-97 D-P Jaguar-2 
  1993 DS Jaguar-2 
XJ12 1994-96 D-P Jaguar-2 
XK Series 2001-04 D-P2, SI Jaguar-4 
  1998-00 D-P Jaguar-1 
  1997 D-P Jaguar-2 
D-P

Driver's & Passenger's Side

D-P2

Driver's & Passenger's Side (Dual-Stage)

DS

Driver's Side

HI

Head Impact

KI

Knee Impact

SI

Side Impact

PS2

Passenger's Side (Dual-Stage)

Jaguar-1

Replace After Deployment Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy) Comments
Deployed air bag modules; Seat assembly(1); Instrument panel & deployment door; Seat belts(2); Deployed seat belt pretensioner; Diagnosis Module (DM); Impact sensors; Knee Bolster; Seat belts & mounting points; Seat belt pretensioner; Single Point Sensing (SPS) unit; Steering column; Steering wheel; If any components are damaged or bent, they must be replaced.; Replacement of all air bag modules is required after 10 years of service.;
(1) If side air bag module deployed, replace seat assembly on side of deployment.
(2) If in use at time of impact.
Jaguar-2

Replace After Deployment Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy) Comments
Deployed air bag modules(1); Diagnosis Module (DM); Impact sensors; Knee bolster; Rear safing sensor; Seat belts & mounting points; Steering column; Steering wheel; If any components are damaged or bent, they must be replaced.; Replacement of all air bag modules is required after 10 years of service.;
(1) Includes sensor assembly
Jaguar-3

Replace After Deployment Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy) Comments
Deployed air bag modules; Seat belts(1); Air bag modules; Electronic Crash Sensor (ECS); Side crash sensors; Seat belts & mounting points; Steering column; Steering wheel; If any components are damaged or bent, they must be replaced.; Electronic Crash Sensor (ECS) replacement is not required until system has incurred 5 separate deployments.;
(1) In use at time of air bag deployment.
Jaguar-4

Replace After Deployment Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy) Comments
Deployed air bag modules; Restraints Control Module (RCM)(1), (2); Deployed seat belt pretensioners; Seat belts(3), (4); Seat assembly(5); Restraints control module (RCM)(2); Impact sensors(2); Instrument panel; Knee Bolster; Seat belts & mounting points; Seat belt pretensioner; Steering column; Steering wheel; If any components are damaged or bent, they must be replaced.; Replacement of all air bag modules is required after 10 years of service.;
(1) Restraints Control Module (RCM) requires replacement if the system has incurred 5 separate deployments. DO NOT replace RCM for less than 5 deployments.
(2) Inspect sensor mounting bracket and pigtail for deformation. If damaged, replace sensor whether or not the air bag has deployed.
(3) Replace all seat belts that were in use at time of collision. (2002-03 X Type only)
(4) All seat belt assemblies should be replaced unless a qualified technician finds the assemblies show no damage and operate correctly. Seat Belt assemblies not in use during a collision should also be inspected and replaced, if either damage or improper operation is noted. (2002-03 X Type only)
(5) If side air bag module deployed, replace seat assembly on side of deployment. (2002-03 XK Series only)
Jaguar-5

Replace After Deployment Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy) Comments
Deployed air bag modules; Restraints Control Module (RCM)(1), (2); Seat belts(3); Seat assembly(4); Headliner, A-pillar & C-pillar trim panels(5); Restraints control module (RCM)(2); Impact sensors(2); Instrument panel; Knee Bolster; Seat belts & mounting points; Seat belt pretensioner; Steering column; Steering wheel; If any components are damaged or bent, they must be replaced.; Replacement of all air bag modules is required after 10 years of service.; DO NOT repair air bag module circuits. Repairs are made by replacement of harness.;
(1) Restraints Control Module (RCM) requires replacement if the system has incurred 5 separate deployments. DO NOT replace RCM for less than 5 deployments
(2) Inspect sensor mounting bracket and pigtail for deformation. If damaged, replace sensor whether or not the air bag has deployed.
(3) Replace seat belts in use at time of collision.
(4) If side air bag module deployed, replace complete seat assembly on side of deployment.
(5) If head impact air bag(s) has deployed. Also, inspect B-pillar trim panel for visible damage or deformation before reusing on vehicle.
scientia non olet · About LEMON Manuals