61 67 045 Removing and installing/replacing spray nozzles for left or right headlight cleaning system

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2006 BMW M3, 2005 BMW M3, 2004 BMW M3, 2003 BMW M3, and 2002 BMW M3. However, it is still accessible from the selected car via links, so may be relevant.

NOTE: Drain fluid tank for windshield washer system

Lever out spray nozzle with telescopic nozzle and pull out up to stop.

Fig 1: Removing Spray Nozzle

G03119610

Courtesy of BMW OF NORTH AMERICA, INC.

Hold telescopic nozzle and pull off spray nozzle.

Allow telescopic nozzle to slowly slide back again.

Installation:

Make sure spray nozzle engages correctly on telescopic nozzle.

Fig 2: Identifying Spray Nozzle On Telescopic Nozzle

G03119611

Courtesy of BMW OF NORTH AMERICA, INC.

Installation:

Do not confuse spray nozzles.

Pay attention to R and L markings on underside of spray nozzles.

Fig 3: Identifying L Marking On Underside Of Spray Nozzles

G03119612

Courtesy of BMW OF NORTH AMERICA, INC.

Replacement only:

Converting spray nozzle finisher:

Unclip both retaining hooks at bottom.

Fig 4: Removing Retaining Hooks At Bottom

G03119613

Courtesy of BMW OF NORTH AMERICA, INC.

Remove spray nozzle finisher upwards from spray nozzle.

Fig 5: Removing Spray Nozzle Finisher

G03119614

Courtesy of BMW OF NORTH AMERICA, INC.

Installation:

Adjust spray nozzles of headlight cleaning system. Refer to 61 67 040 ADJUSTING SPRAY NOZZLES FOR HEADLIGHT CLEANING SYSTEM .