Section 90 (Engine Assembly, Cylinder Head, Oil Pan, Timing Case Cover, Crankcase Ventilation System - Repair)
WARNING: This page is about a different variant/trim than selected.
- Engine Assembly
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 00 Safety instructions for handling oil
- 11 00 039 Checking compression of all cylinders (N55)
- 11 00 000 Differences among basic engine versions (N63/S63)
- Engine identification
- 11 00 300 Engine oil consumption measurement
- 11..... Equipment recoding special tool number of the transverse member for fixing the engine in the installation location
- 11 00... Handling components after flood damage
- 11 00 Mounting engine on assembly stand (N55)
- 11 00 Mounting Engine On Assembly Stand (N63)
- 11 00 Mounting Engine On Assembly Stand (S63)
- 11 00... Overview of consumables (BMW Electronic Parts Catalogue)
- 11 00 050 Removing and installing engine (N55)
- 11 00 598 Removing and installing engine on front axle (S63) with GS7D36SG transmission (M6, Dual-clutch transmission)
- 11 00 598 Removing and installing engine on front axle (S63) with GS6-53BZ transmission (M6, Manual transmission)
- 31 10 001 Completely removing and installing front axle with engine and transmission (S63, DKG)
- 31 10 001 Completely removing and installing the front axle with engine and transmission (S63, manual gearbox)
- 11 00 598 Removing and installing engine on front axle (N63O1) with GA8HP70Z all-wheel drive vehicle transmission
- 11 00 598 Removing and installing engine on front axle (N63O1) with GA8HP70Z transmission
- 11 00 598 Removing and installing engine on front axle (N63O1) with manual gearbox
- 11 00 050 Removing and installing/replacing engine (N63)
- 12 00 Removing and installing/replacing ignition coil cover (N55)
- 11 00 Removing and installing/replacing the acoustic cover (N63 B44 O 0/1)
- 11 00 670 Securing engine in installation position (N55)
- 11 00 670 Securing engine in installation position (N63)
- 11 00 670 Securing engine in installation position (N63O1)
- 11 00 670 Securing engine in installation position (S63)
- 11 00... Service - engine oil (N55)
- 11 00... Service - engine oil (N63)
- 11 00... Service - engine oil (N63O1)
- 11 00... Service engine oil (S63)
- Cylinder Head, Valve Cover
- 11 12 729 Checking cylinder head for water leaks (N55)
- 11 12 729 Checking cylinder head for watertightness (N63)
- 11 12 729 Checking cylinder head on watertightness (N63O1)
- 11 12 729 Checking cylinder head on watertightness (S63)
- 11 12 040 Removing and installing all ignition coils and injector wells (N55)
- 11 12 100 Removing and installing cylinder head (N55)
- 11 12 105 Removing and installing left cylinder head (N63)
- 11 12 106 Removing and installing right cylinder head (N63)
- 11 12 105 Removing and installing left cylinder head (N63O1)
- 11 12 106 Removing and installing right cylinder head (N63O1)
- 11 12 106 Removing and installing right cylinder head (S63)
- 11 12 105 Removing and installing left cylinder head (S63)
- 11 12 000 Removing and installing/sealing cylinder head cover (N55)
- 11 12 005 Removing and installing/sealing left cylinder head cover (N63)
- 11 12 006 Removing and installing/sealing right cylinder head cover (N63)
- 11 12 005 Removing and installing/sealing left cylinder head cover (N63O1)
- 11 12 006 Removing and installing/sealing right cylinder head cover (N63O1)
- 11 12 005 Removing and installing/sealing left cylinder head cover (S63)
- 11 12 006 Removing and installing/sealing right cylinder head cover (S63)
- 11 12 101 Replacing cylinder head gasket (N55)
- 11 12 112 Replacing both cylinder head gaskets (N63)
- 11 12 112 Replacing both cylinder head gaskets (N63O1)
- 11 12 112 Replacing both cylinder head gaskets (S63)
- 11 12 719 Surface grinding cylinder head lower face (N55)
- 11 12 719 Surface grinding cylinder head sealing surface (N63)
- 11 12 719 Surface grinding cylinder head lower face (N63O1)
- 11 12 719 Surface grinding cylinder head lower face (S63)
- 11 15 140 Replace oil separator (N63)
- 11 15 140 Replace oil separator (N63O1)
- 11 12 090 Removing engine cover (S63)
- Engine Oil Pan
- 11 13 000 Removing and installing, sealing or replacing oil sump (N55, RWD)
- 11 13 000 Removing and installing, sealing or replacing oil sump (N55, AWD)
- 11 13 020 Removing and installing/replacing lower oil sump section (N63)
- 11 13 010 Removing and installing/replacing upper oil sump section (N63)
- 11 13 020 Removing and installing/replacing lower oil sump section (N63O1)
- 11 13 010 Removing and installing/replacing upper oil sump section (N63O1)
- 11 13 020 Removing and installing/replacing lower oil sump section (S63)
- 11 13 010 Removing and installing/replacing upper oil sump section (S63)
- Timing Case Cover, Crankshaft Seal
- 11 14 010 Replacing sealing cap for vacuum pump (N55)
- 11 14 015 Removing and installing/replacing sealing cap for oil pump chain tensioner (N55)
- 11 14 110 Removing and installing lower timing case cover (N63)
- 11 14 080 Removing and installing timing case cover, top left (N63)
- 11 14 085 Removing and installing timing case cover, top right (N63)
- 11 14 250 Removing and installing/sealing rear coolant end cover (N63)
- 11 14 110 Removing and installing lower timing case cover (N63O1)
- 11 14 080 Removing and installing timing case cover, top left (N63O1)
- 11 14 085 Removing and installing timing case cover, top right (N63O1)
- 11 14 110 Removing and installing bottom gear case cover (S63)
- 11 14 080 Removing and installing gear case cover, top left (S63)
- 11 14 085 Removing and installing gear case cover, top right (S63)
- 11 14 005 Replacing front crankshaft seal (N55) - up to 02.2014
- 11 14 005 Replacing front crankshaft seal (N55) - from 02.2014
- 11 14 151 Replacing radial crankshaft seal on transmission side (N55)
- 11 14 141 Replacing radial shaft seal in lower timing case cover (N63)
- 11 14 151 Replacing crankshaft radial seal on transmission side (N63)
- 11 14 141 Replacing radial shaft seal in lower gear case cover (N63O1)
- 11 14 151 Replacing the crankshaft seal on the transmission side (N63O1)
- 11 14 141 Replacing radial shaft seal in bottom gear case cover (S63)
- 11 14 151 Replacing crankshaft seal on the transmission side (S63)
- Crankcase Ventilation System
- 11 15 001 Replacing all engine ventilation lines and actuating wires
- 11 15 007 Replacing connecting line on left
- 11 15 008 Replacing right connecting line
- 11 15 015 Remove/install/replace engine ventilation line
- 11 15 016 Removing and installing/replacing engine ventilation connecting line
- 11 15 140 Replace oil separator (N63)
- 11 15 140 Replace oil separator (N63O1)
- 11 15 002 Replacing engine crankcase ventilation line for cylinders 1-4 (N63)
- 11 15 003 Replacing engine crankcase ventilation line for cylinders 5-8 (N63)