Install oil pump
- Remove engine oil line (1) from the oil pump in the arrow direction.
- Remove oil feed line (2)
from the oil pump in the arrow direction.
- Replace the O-rings (1)
and (2)
.
Parts: O-rings
- Grease the O-rings (1)
and (2)
.
- Replace the O-ring (1)
in the crankcase.
Parts: O-ring
- Install oil feed line (1)
and engine oil line (2)
in the crankcase.
- Install the oil pump (3) .
- Replace the nuts (1)
and apply hand-tight.
Parts: Nuts
- Replace the screw (2)
and apply hand-tight.
Parts: Screw
Oil pump (3) must rest against the bearing journal.
- Guide the sprocket in the roller chain and position it on the oil pump.
- Tighten the bolts (1) with the special tool 0 493 434 (11 7 200) .
TIGHTENING TORQUE SPECIFICATIONS
| Oil pump drive gear to hub | ||
|---|---|---|
| M6 | Tightening torque | 10 Nm |
- Install the base plate (A) of the special tool 2 413 036 with the screws (1) .
- Tighten down screws (1) .
TIGHTENING TORQUE SPECIFICATIONS
| Oil pan 17 Nm | ||
|---|---|---|
| M8 x 25 Replace screws. |
Tightening torque | 17 Nm |
- Attach the special tool 2 413 036 with the screws (1) on the base plate.
- Tighten down screws (1) .
TIGHTENING TORQUE SPECIFICATIONS
| Standard screw connection M8 | ||
|---|---|---|
| M8 | Tightening torque | 19 Nm |
NOTE:
TECHNICAL INFORMATION
Do not use force preload timing chain.
Do not use force preload timing chain.
- Press the secondary indicator (1) of the special tool 2 413 036 to the left and right and determine the value.
TECHNICAL DATA SPECIFICATION
| Adjustment value for oil pump timing chain | ||
|---|---|---|
| 10 +1-3 mm | ||
NOTE:
To provide a better overview: Shown without oil pan.
- Pretension the roller chain by turning the adjusting sleeve (1) until the setpoint value has been reached.
TECHNICAL DATA SPECIFICATION
| Adjustment value for oil pump timing chain | ||
|---|---|---|
| 10 +1-3 mm | ||
- Tighten the nuts (1) on the oil pump (3) .
TIGHTENING TORQUE SPECIFICATIONS
| Oil pump to bearing journal | ||
|---|---|---|
| Nut M8 | Tightening torque | 24 Nm |
- Tighten down screw (2) .
TIGHTENING TORQUE SPECIFICATIONS
| Oil pump to bearing journal adjustment screw | ||
|---|---|---|
| M8x45 | Tightening torque | 24 Nm |
- Press the secondary indicator (1) of the special tool 2 413 036 to the left and right and check the value again.
TECHNICAL DATA SPECIFICATION
| Adjustment value for oil pump timing chain | ||
|---|---|---|
| 10 +1-3 mm | ||
- Remove the special tool 2 413 036
.
- Check banjo bolt (1) for contamination and, if necessary, clean it.
- Check O-ring (2)
for damage and, if necessary, replace the control line.
- Install the control line (3) .
- Tighten the banjo bolt (2) .
TIGHTENING TORQUE SPECIFICATIONS
| Control line to crankcase | ||
|---|---|---|
| M10 | Tightening torque | 23 Nm |
- Tighten down screw (1) .
TIGHTENING TORQUE SPECIFICATIONS
| Control line to oil pump | ||
|---|---|---|
| M6x16 | Tightening torque | 10 Nm |
- Install the intake pipe with oil strainer (5) .
- Replace the O-rings of the bolts (4)
.
Parts: O-rings
- Tighten down screws (4) .
TIGHTENING TORQUE SPECIFICATIONS
| Oil intake manifold to oil pump | ||
|---|---|---|
| M6 | Tightening torque | 10 Nm |
Follow-up work
- Refer to INSTALLING THE LOWER OIL PAN SECTION .
- Refer to INSTALLING THE OIL FILTER ELEMENT .
- Refer to TIGHTENING THE OIL FILTER CAP .
- Refer to TIGHTENING THE OIL DRAIN PLUG .
- Refer to INSTALLING THE STIFFENING PLATE .
- Refer to INSTALLING THE UNDERBODY PROTECTION OF THE STEERING GEAR OR THE FRONT THRUST FIELD .
- Refer to INSTALLING THE FRONT UNDERBODY PROTECTION OR FRONT THRUST FIELD .
- Refer to TOPPING UP THE MOTOR OIL .
- Refer to CLOSING THE OIL FILLER CAP .
- Refer to FOLDING THE ACOUSTIC COVER CLOSED .