LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2015 >> Z4 sDrive35is >> Repair and Diagnosis >> External Pages >> Different car >> Section 542 (Front Axle - Repair) >> Output Shaft >> 31 60 000 Removing and installing/replacing left or right output shaft

31 60 000 Removing and installing/replacing left or right output shaft

WARNING: This page does not describe the selected car, but rather 18 other vehicles, including the 2015 BMW Alpina B7L xDrive, 2015 BMW Alpina B7 xDrive, 2015 BMW 750i xDrive, 2015 BMW 750Li xDrive, and 2015 BMW 740Li xDrive. However, it is still accessible from the selected car via links, so may be relevant.

Necessary preliminary work: 

IMPORTANT:

Risk of damage!

Secure output shaft against falling out.

Knock out left or right output shaft using an aluminium spike (2) at the front axle differential/bearing support.

Fig 1: Removing Output Shaft From Front Axle Differential/Bearing Support Using Aluminium Drift
G08512350Courtesy of BMW OF NORTH AMERICA, INC.

Installing the output shaft: 

NOTE: The installation protective ring (1) serves to protect the sealing lips of the radial shaft seal (2) when installing the output shaft.

Open installation protective ring (1).

Fig 3: Identifying Radial Shaft Seal And Protective Ring
G04794385Courtesy of BMW OF NORTH AMERICA, INC.
IMPORTANT: When installing output shaft, make sure that tripod does not fall into gaiter

Press swivel bearing slightly to one side and insert output shaft into front axle differential/bearing support.

Pull out assembly protection ring at lug (1) until one of the two predetermined breaking points gives.

Fig 4: Identifying Assembly Protection Ring
G04794415Courtesy of BMW OF NORTH AMERICA, INC.

Slide output shaft to the limit position into front axle differential. Output shaft must snap audibly into place.

Installation note: 

IMPORTANT: The following must be observed without fail: