LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2015 >> Z4 sDrive28i, Automatic Trans >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 6 (Maintenance And General Information - Repair (N54) -- Z4_E89) >> Check, Add, Change Transmission Oil >> 00..... Information on service functions for twin-clutch gearbox (GS7D36SG)

00..... Information on service functions for twin-clutch gearbox (GS7D36SG)

WARNING: This page is about a different variant/trim than selected.
NOTE: The service functions must be carried out in the relevant order!
Replacement of clutch and after all work on opened transmission
  1. Carry out fluid adjustment
  2. Reset torque characteristics
  3. Teach in valve characteristic curves
  4. Teach in kiss point
  5. Parking lock hook test
Replacement of oil pump and after all work on opened transmission
  1. Carry out fluid adjustment
  2. Teach in valve characteristic curves
  3. Teach in kiss point
  4. Parking lock hook test
Replacement of Mechatronics
  1. Read out transmission data before replacement
  2. Replace Mechatronics
  3. Write transmission data
  4. Carry out fluid adjustment
  5. Teach in valve characteristic curves
  6. Teach transmission
  7. Teach in kiss point
  8. Parking lock hook test
Replacement of transmission (complete)
  1. Parking lock hook test
  2. Carry out fluid adjustment
Replacement/repair of parking lock cable, selector lever with parking lock unit
  1. Parking lock hook test
Replacement of combination sensor
  1. Carry out fluid adjustment
  2. Teach in valve characteristic curves
  3. Teach in kiss point
  4. Parking lock hook test
Opening/replacement of fluid adjusting screw, repair/replacement of transmission oil cooler, oil cooler lines, thermostat, water/oil heat exchanger (M3) and gaskets
  1. Carry out fluid adjustment
scientia non olet · About LEMON Manuals