LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2013 >> Z4 28i, Automatic Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 494 (Collision - Body Panel Repair (F01, F02) (AWD)) >> Wheel Wells >> 41 14 500 Replacing Outer Section Of Left Or Right Rear Wheel Housing (Side Panel Removed)

41 14 500 Replacing Outer Section Of Left Or Right Rear Wheel Housing (Side Panel Removed)

WARNING: This page does not describe the selected car, but rather 18 other vehicles, including the 2015 BMW Alpina B7L xDrive, 2015 BMW Alpina B7 xDrive, 2015 BMW 750i xDrive, 2015 BMW 750Li xDrive, and 2015 BMW 740Li xDrive. However, it is still accessible from the selected car via links, so may be relevant.

Read contents of BODY, GENERAL .

Spot-weld bonding is used on this vehicle. Observe specific procedure. See OPENING ADHESIVE BONDS  and SPOT-WELD BONDING STEEL COMPONENTS .

Remove or cover those vehicle components in the repair area which are susceptible to heat or dust.

Use only approved SPOT-WELDING APPARATUS  for repairs.

Necessary preliminary tasks: 

Remove COVER FOR REAR SIDE MEMBER 

The following new body parts are required :

Removal of outer wheel arch section 

Fig 2: Identifying Severance Cut Mark, Cavity Acoustic Baffles, Sheet Section, Riveted And Welded Joint Areas
G08525983Courtesy of BMW OF NORTH AMERICA, INC.

Mark severance cut (1) in accordance with measurement and cut.

IMPORTANT: Cut outer panel only.
Measurement a = approx. 30 mm from centerpoint of 14 mm dia. hole.
Open welded connections in areas (2).
Fold sheet section (3) forwards and open weld joints in area (4).
Open rivet joints in area (5).
Remove sheet section.
Installation note:
Weld in REINFORCEMENT PLATE  at severance cut.
Replace both CAVITY ACOUSTIC BAFFLES  (6).
No rivet connection in area (5). Weld new part.

Open spot-weld bonded joints in area (1)

Open welded connections in area (2).

Remove outer section of wheel arch.

Fig 3: Identifying Spot-Weld Bonded Joints Area And Welded Connections Area
G08525984Courtesy of BMW OF NORTH AMERICA, INC.

Preparation of new part 

Mark severance cut on C-pillar reinforcement and cut.

Adjust new parts in conjunction with side panel to fit.

Installation of outer wheel arch section 

Install and weld new parts.