LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2012 >> 535i Automatic Trans >> Repair and Diagnosis >> Engine Mechanical >> Cooling System (Mechanical) >> Engine - Variable Valve Timing Control System (VANOS), Intake Plenum, Turbocharger, Water Pump, Thermostat, Coolant Lines, EGR Valve, EGR Cooler, Oxygen Sensors - Repair >> Variable Valve Timing Control System (VANOS) >> S63 Engine >> 11 36 720 Removing and installing/replacing both solenoid valves on right side (S63)

11 36 720 Removing and installing/replacing both solenoid valves on right side (S63)

IMPORTANT: Always check that the solenoid valves are clean during removal and installation.
Possible malfunctions if valves are contaminated:
  • Irregular operation
  • OBD incorrect entry
  • Poor exhaust gas values
  • Low engine performance
IMPORTANT: Risk of damage. 
Do not clean solenoid valves with compressed air.

Solenoid valves, cylinders 1-4: 

Necessary preliminary tasks: 

Unlock plug connections of solenoid valves (1 and 2) and disconnect.

Installation note: 

Plug connections must snap audibly into place.

Fig 1: Identifying Plug Connections Of Solenoid Valves
G09924103Courtesy of BMW OF NORTH AMERICA, INC.
NOTE: Solenoid valve (4) controls the exhaust adjustment unit.
Solenoid valve (2) controls the intake camshaft adjuster.

Release screws (1 and 3).

Tightening torque 11 36 3AZ .

Pull out solenoid valves.

Fig 2: Identifying Solenoid Valves And Screws
G09924104Courtesy of BMW OF NORTH AMERICA, INC.

Installation note: 

Replace O-rings (1 and 2) on solenoid valve  .

Installation note: 

To install solenoid valves, coat both O-rings with engine oil.

If the solenoid valve is to be reused, the filter strainer (see arrow) must be cleaned.

Fig 3: Locating O-Rings On Solenoid Valve
G09924105Courtesy of BMW OF NORTH AMERICA, INC.
NOTE: If a filter element is clogged with dirt, the filter element (filter strainer) may be removed.

Release filter elements (1) at contact edges.

Fig 4: Locating Filter Elements
G09924106Courtesy of BMW OF NORTH AMERICA, INC.

Bend open welding spots on filter element (1) with a screwdriver (2) in direction of arrow until welding spots are opened.

Fig 5: Bending-Open Weld Spots On Filter Element Using Screwdriver
G09924107Courtesy of BMW OF NORTH AMERICA, INC.

Avoid damaging, e.g. notches or scratches, the solenoid valve housing (see arrows).

Apply engine oil to O-ring.

Fig 6: Identifying Solenoid Valve Housing
G09924108Courtesy of BMW OF NORTH AMERICA, INC.

Gently insert solenoid valves as far as stop.

Ensure correct installation position.

Insert screws (1 and 3) and tighten down.

Tightening torque 11 36 3AZ .

Fig 7: Identifying Solenoid Valves And Screws
G09874592Courtesy of BMW OF NORTH AMERICA, INC.

Assemble engine.

Delete fault memory.

Check function of DME.