The following additionally applies
WARNING: This page is about a different car, the 2010 BMW M6, 2009 BMW M6, and 2008 BMW M6. However, it is still accessible from the selected car via links, so may be relevant.
Shielded lines
Contact points in the shield can cause problems with regard to noise radiation and interference immunity. Consequently, distinctions have to be drawn between the following types:
Coaxial line
- Shielded RTK031 coaxial lines may only be repaired with special crimping tool for repairing the coaxial line RTK031.
CVBS lines
- CVBS lines may not be repaired.
- CVBS lines must be replaced in their entirety.
HSD lines
- HSD lines may not be repaired.
- HSD lines must be replaced in their entirety.
Optical fibre cable:
NOTE:
Optical fibre cables are colored differently as follows:
- Green = MOST (M edia O riented S ystems T ransport) optical fibre
- Yellow = ISIS (I ntelligent S afety I ntegration S ystem) optical fibre
- Orange = repair optical fibre cables
IMPORTANT:
- Optical fibre cables are permitted to show only one separation point (bridge), replace optical fibre cables if necessary
- Smallest permissible bending radius is 25 mm
- Avoid influence of heat ≥ 85 °
FlexRay:
It is possible to repair the FlexRay. In the event of damage, the cables can be joined with conventional butt connectors.
NOTE:
- The line is a twisted cable. If possible, maintain twist in line after repair.
Airbag lines:
See 61 00... REPAIRING AIRBAG CABLES .
Ribbon cables: