63 12 010 Removing And Installing/Replacing Left Headlight (Xenon Headlight)

WARNING: This page does not describe the selected car, but rather 10 other vehicles, including the 2007 BMW 550i, 2007 BMW 530xi, 2007 BMW 530i, 2007 BMW 525xi, and 2007 BMW 525i. However, it is still accessible from the selected car via links, so may be relevant.

WARNING:

Follow instructions for HANDLING LIGHT BULBS (EXTERIOR LIGHTS) .

Unclip strip (1) in direction of arrow.

Release screws (2) underneath.

Fig 1: Identifying Strip And Screw

G04957773

Courtesy of BMW OF NORTH AMERICA, INC.

Turn cap (1) approx. 30° counterclockwise and remove from headlight (2).

Fig 2: Identifying Cap And Headlight

G04957774

Courtesy of BMW OF NORTH AMERICA, INC.

Slacken screws (1)

Unfasten screws (2).

Installation:

Observe GAP DIMENSIONS
Adjust HEADLIGHTS

Fig 3: Identifying Screws

G04957775

Courtesy of BMW OF NORTH AMERICA, INC.

Pull bumper panel (1) forwards slightly and feed out headlight (2) in direction of arrow.

Installation:

Make sure headlight (2) is correctly seated in lower holder.

Unlock and disconnect associated plug connections (3).

Remove headlight (2).

Fig 4: Identifying Bumper Panel And Headlight

G04957776

Courtesy of BMW OF NORTH AMERICA, INC.

Replacement:

Unclip headlight holder (1) and remove.
Remove IGNITION UNIT AND BULB FOR XENON HEADLIGHT (2)
Remove CONTROL UNIT FOR XENON HEADLIGHT (3)

Fig 5: Identifying Headlight Holder

G04957777

Courtesy of BMW OF NORTH AMERICA, INC.

Installation:

Retaining lugs (1) on headlight holder (2) must not be damaged.

Make sure headlight holder (2) is correctly engaged on headlight.

Fig 6: Identifying Headlight Holder And Lugs

G04957778

Courtesy of BMW OF NORTH AMERICA, INC.