LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2009 >> 650i 2D Convertible, Automatic >> Repair and Diagnosis >> External Pages >> Different car >> Section 1431 (Brakes - Repair) >> 11 Front Brakes >> 34 11 000 Removing and Installing/Replacing Brake Linings On Both Front Disc Brakes (1 Piston)

34 11 000 Removing and Installing/Replacing Brake Linings On Both Front Disc Brakes (1 Piston)

WARNING: This page is about a different car, the 2010 BMW X5, 2009 BMW X5, 2008 BMW X5, and 2007 BMW X5. However, it is still accessible from the selected car via links, so may be relevant.

Special tools required: 

IMPORTANT:

The brake pad wear sensor must be replaced once it has been removed (brake pad wear sensor loses its retention capability in the brake pad). 

Necessary preliminary tasks: 

Lever out retaining spring (1) in direction of arrow towards rear.

Installation: 

Attach retaining spring (1) first at top and bottom on brake caliper and then allow to engage in recesses of brake caliper housing.

Fig 1: Removing Retaining Spring
G04794690Courtesy of BMW OF NORTH AMERICA, INC.

Remove plastic plugs (1).

If necessary, when replacing linings, reset CBS display in accordance with factory specification.

Release guide screws (2) with special tool 34 1 080. See 34 1 080 BIT INSERT . Withdraw brake caliper backwards.

IMPORTANT: Tie brake caliper back and do not allow to hang from brake hose.
Fig 2: Identifying Plastic Plugs
G04742621Courtesy of BMW OF NORTH AMERICA, INC.

Left:

Pull brake lining wear sensor (1) towards rear out of lining.

If necessary, replace brake lining wear sensor.

Installation: 

Only clean guide screws; do not grease.

Check threads.

Replace all guide screws which are not in perfect condition.

Tightening torque 34 11 4AZ. See 34 11 FRONT BRAKE

Fig 3: Pulling Brake Lining Wear Sensor
G04742622Courtesy of BMW OF NORTH AMERICA, INC.

Remove outer brake pad (1) in direction of arrow.

Force inner brake pad (2) in direction of arrow off piston and remove.

The inner brake pad is seated with a spring in the piston or in the brake caliper housing.

IMPORTANT: Mark any worn brake linings.

In the event of one-sided brake lining wear, do not change brake linings round.

Observe minimum thickness of brake pads. See 34 11 FRONT BRAKE E70

Clean brake linings.

Do not apply grease to brake pad backplate.

Fig 4: Removing Outer Brake Pad
G04794693Courtesy of BMW OF NORTH AMERICA, INC.
IMPORTANT: When forcing piston back:
  • Pay attention to brake fluid level in expansion tank; brake fluid that spills over will damage paintwork.

    Press back brake pads and piston with special tool 34 1 050. See 34 1 050 FIXTURE

    Fig 5: Identifying Special Tool (34 1 050)
    G04794694Courtesy of BMW OF NORTH AMERICA, INC.

Check minimum brake disc thickness:

New brake linings may only be installed if the brake disc thickness is greater than or equal to the minimum brake disc thickness (MIN TH). See34 11 FRONT BRAKE E70 .

Fig 6: Identifying Special Tool (34 1 280)
G04726574Courtesy of BMW OF NORTH AMERICA, INC.

Check dust sleeve (2) for damage and replace if necessary.

Clean contact face (1) of brake piston and apply a thin coating of anti-squeak compound  .

IMPORTANT: Dust sleeve must not come into contact with anti-squeak compound as this may cause the dust sleeve to swell.
Fig 7: Identifying Dust Sleeve
G04794696Courtesy of BMW OF NORTH AMERICA, INC.

Clean mounting faces (1) and (2) of brake lining hammer heads/brake caliper housing and coat with Plastilube.

NOTE: Grease contact surfaces on brake caliper at top and bottom.
Fig 8: Identifying Mounting Faces And Brake Lining Hammer Heads
G04794697Courtesy of BMW OF NORTH AMERICA, INC.

Clean mounting face (1) of brake caliper and apply a thin coating of Plastilube.

Fig 9: Identifying Mounting Face Of Brake Caliper
G04794698Courtesy of BMW OF NORTH AMERICA, INC.

Clean hammerhead guides (1) and apply a thin coating of Plastilube.

Fig 10: Identifying Hammerhead Guides
G04794699Courtesy of BMW OF NORTH AMERICA, INC.
NOTE: After completing work:
  • Fully depress brake pedal several times so that brake linings contact brake discs.
  • When installing new brake linings at front and rear axles, brake fluid level must be brought up to "MAX" marking.
  • Read and comply with notes on braking in new brake discs / brake pads. See 34 00 ... General Information On Braking In New Brake Discs / Brake Pads 
  • When replacing pads, reset CBS display in accordance with factory specification.