LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2009 >> 650i 2D Convertible, Automatic >> Repair and Diagnosis >> External Pages >> Different car >> Section 1430 (Rear Axle - Repair) >> 53 Springs With Suspension >> 33 53 000 Removing And Installing / Replacing Rear Left Or Right Coil Spring

33 53 000 Removing And Installing / Replacing Rear Left Or Right Coil Spring

WARNING: This page is about a different car, the 2010 BMW X5, 2009 BMW X5, 2008 BMW X5, and 2007 BMW X5. However, it is still accessible from the selected car via links, so may be relevant.

Special tools required: 

IMPORTANT: Use spring tensioner 33 5 100  to remove and install the coil spring in order to avoid over elongating the rubber mounts (control arm, guide arm, swinging arm).
WARNING: Observe the following instructions to avoid any risk of injury by the coil springs.
  1. Prior to each use, check the special tools for defects, modifications and operational reliability.
  2. Damaged/modified special tools must not be used!
  3. No changes or modifications may be made to the special tools!
  4. These special tools are intended solely for the purpose of tightening and relieving cylindrical and tapered suspension springs.
  5. Keep special tools dry, clean and free of grease.
  1. 7. Do not compress coil spring to full extent.
  2. 8. Observe manufacturer's instructions.
IMPORTANT: Both coil springs on the relevant axle must be replaced only in the event of corrosion breakage!
Avoid damaging the coil spring coating.

Necessary preliminary tasks: 

Removal: 

Lever conical cover (1) with a suitable tool out of lower spring pad.

Fig 1: Identifying Conical Cover
G04794657Courtesy of BMW OF NORTH AMERICA, INC.

Feed spindle 33 5 103  into coil spring and turn thrust piece 33 5 104  downwards.

Fig 2: Identifying Spindle (33 5 103) And (33 5 104)
G04794658Courtesy of BMW OF NORTH AMERICA, INC.

Insert lower spring retainer 33 5 102  into coil spring and turn downwards over spindle 33 5 103  .

Fig 3: Identifying Lower Spring Retainer (33 5 102) And (33 5 103)
G04794659Courtesy of BMW OF NORTH AMERICA, INC.

Insert upper spring retainer 33 5 101  sideways into coil spring and turn fully upwards.

WARNING: Danger of injury!
Align spring tensioner 33 5 100  centrally in order to obtain the largest possible contact surface on the coil spring.
Make sure hexagon cap (1) is correctly seated in upper spring retainer 33 5 101  .
Fig 4: Identifying Hexagon Cap And Upper Spring Retainer (33 5 101)
G04794660Courtesy of BMW OF NORTH AMERICA, INC.
WARNING: Danger of injury!
Make sure coil spring is correctly positioned in spring plates.
Fig 5: Identifying Coil Spring Position In Spring Plates
G04726549Courtesy of BMW OF NORTH AMERICA, INC.
WARNING: Danger of injury!
Make sure detent pin (1) is correctly positioned in recesses of lower spring retainer 33 5 102  .
Fig 6: Identifying Detent Pin And Lower Spring Retainer (33 5 102)
G04794662Courtesy of BMW OF NORTH AMERICA, INC.

Check installation position of spring tensioner (33 5 100  ), correct if necessary.

NOTE: Make sure there is sufficient clearance (A = 7 cm) between spindle 33 5 103  and lower spring pad.

Tension coil spring using special tool 33 5 105;  if necessary, grip coil spring.

Fig 7: Identifying Clearance Between Spindle (33 5 103) And Lower Spring Pad
G04794663Courtesy of BMW OF NORTH AMERICA, INC.

Turn coil spring through A = 30° in counterclockwise direction.

Press wheel carrier downwards a little and remove coil spring sideways.

Fig 8: Turning Coil Spring
G04794664Courtesy of BMW OF NORTH AMERICA, INC.

Remove upper spring pad (1) from coil spring, check for damage and replace if necessary.

If necessary, relieve tension on coil spring.

Fig 9: Identifying Upper Spring Pad And Upper Section
G04794665Courtesy of BMW OF NORTH AMERICA, INC.

Installation: 

Check lower spring pad (1) for damage.

IMPORTANT: Make sure spring pad is correctly installed in order to prevent the coil spring from jumping out.

If necessary, lever out upper section (2) with a suitable tool and replace spring pad with upper section.

Fig 10: Identifying Lower Spring Pad And Upper Section
G04794632Courtesy of BMW OF NORTH AMERICA, INC.
IMPORTANT: Make sure spring pad is correctly installed in order to prevent the coil spring from jumping out.

Install upper spring pad (1) in locator or frame side member and turn clockwise as far as it will go.

Fig 11: Identifying Spring Pad
G04794667Courtesy of BMW OF NORTH AMERICA, INC.
IMPORTANT: Make sure coil spring is correctly seated in spring pads.

Insert coil spring with spring tensioner 33 5 100  between upper and lower spring pads and relieve tension.

Relieve tension on spring tensioner 33 5 100  and remove.

Fig 12: Identifying Spring Tensioner (33 5 100)
G04794668Courtesy of BMW OF NORTH AMERICA, INC.

After installation: