72 12... Procedure after airbag deployment as result of an accident

WARNING: This page is about a different car, the 2010 BMW M5, 2009 BMW M5, 2008 BMW M5, 2007 BMW M5, and 2006 BMW M5. However, it is still accessible from the selected car via links, so may be relevant.

Check and/or replace following components after airbag triggering:

Satellites (control unit + sensor)

Components
- Satellite, A-/B-pillar, left/right
- Satellite, front door
- Satellite, rear seat
- Satellite, driver's/front passenger seat
- Satellite, vehicle center
Procedure
- Read out fault memory
- Disconnect battery and observe waiting period
- Rectify faults
- Reconnect battery and observe waiting period
- Clear fault memory
- Turn off ignition and wait at least 2 minutes (no consumers may be switched on during this period such as e.g. inside lights, radio, etc.)
- Switch ignition on.
- Clear fault memory and if necessary rectify faults

Cables and plugs

Components and procedure
- Check cables and plugs for damage, replace if necessary.

Belt system

Components
- Automatic safety belt tensioner
- Belt buckle tensioner
- Seatbelt height adjustment
Procedure
- Check components, replace if necessary

Seats

Components
- Seat
- Airbag module
- Active head restraint
- Procedure
  - Check seats (function check of seat mechanism), replace if necessary
  - Check seat screw/bolt connections
  - Replace gas generator of active head restraint system
    If the severity of the impact has not caused any other damage to the seat, only the triggered gas generator needs to be replaced.
    
    External feature: The triggered head restraint is folded forwards and engaged.
    
    The repair work can be carried out in the car with the rear panel removed. The entire system can be pushed back into its original position and the new gas generator installed.
    
    The gas generator can be replaced up to 5 times.
  - Replace airbag module and seat cover with padding
Driver's airbag
- Components
  - Airbag module
  - Steering wheel
  - Steering column (if damaged)
- Procedure
  - Check components, replace if necessary
  - Replace steering wheel
Passenger airbag
- Components
  - Airbag module
  - Instrument panel trim
  - Supporting tube (if damaged)
- Procedure
  - Check components, replace if necessary
Side airbag, front/rear
- Components
  - Airbag module Door trim panel
  - Door in white
  - Seat
- Procedure
  - Check components, replace if necessary
Head airbag (AHPS)
- Components
  - Airbag module
  - Trim, A-pillar
  - Roofliner
  - Trim, B-pillar (if damaged)
  - Trim, C-pillar (if damaged)
  - Bodyshell
- Procedure
  - Check components, replace if necessary
Knee airbag
- Components
  - Panel (driver's side)
  - Lower section of glovebox
  - Active knee protector (driver's and passenger sides)
- Procedure
  - Check components, replace if necessary
Passive knee protector
- Components
  - Panel (driver's side)
  - Glovebox incl. knee protector (passenger side)
- Procedure
  - Check components for damage, replace if necessary
  - Check fastening elements