Section 2667 (Intake Plenum, Turbocharger, Vacuum Pump, EGR Valve, Oxygen Sensors - Repair)
WARNING: This page does not describe the selected car, but rather 27 other vehicles, including the 2017 BMW M6, 2017 BMW 650i xDrive, 2017 BMW 650i, 2017 BMW 640i xDrive, and 2017 BMW 640i. However, it is still accessible from the selected car via links, so may be relevant.
- Intake Plenum
- 11 61 365 Removing and installing/replacing front left charge air duct (N55)
- 11 61 368 Removing and installing/replacing rear left charge-air duct (N55)
- 11 61 050 Removing and installing intake plenum (N55)
- 11 61 065 Removing and installing/replacing left intake plenum (N63)
- 11 61 068 Removing and installing/replacing right intake plenum (N63)
- 11 61 065 Removing and installing/replacing left intake plenum (N63O1)
- 11 61 068 Removing and installing/replacing right intake plenum (N63O1)
- 11 61 065 Removing and installing/replacing left intake plenum (S63)
- 11 61 068 Removing and installing/renewing right intake plenum (S63)
- 11 61 730 Check BMW diagnosis system for excess pressure and vacuum (N63)
- 11 61 730 BMW leakage test for intake system (N63O1)
- Turbocharger
- 11 65 300 Adjusting electrical controller drive (wastegate valve) (N55)
- 11 65 165 Removing and installing/replacing blow-off valve (N63)
- 11 65 180 Removing and installing/renewing heat shield at top (N63)
- 11 65 185 Removing and installing/renewing heat shield at bottom (N63)
- 11 65 180 Removing and installing/renewing heat shield at top (N63O1)
- 11 65 185 Removing and installing/renewing heat shield at bottom (N63O1)
- 11 65 180 Removing and installing/replacing top heat shield (S63)
- 11 65 185 Removing and installing/replacing heat shield, bottom (S63)
- 11 65 020 Removing and installing/replacing exhaust turbocharger (N55)
- 11 65 025 Removing and installing/replacing exhaust turbocharger, right, cylinders 1-4 (N63)
- 11 65 030 Removing and installing/replacing exhaust turbocharger, left, cylinders 5-8 (N63)
- 11 65 025 Removing and installing/replacing exhaust turbocharger, right, cylinders 1-4 (N63O1)
- 11 65 030 Removing and installing/replacing exhaust turbocharger, left, cylinders 5-8 (N63O1)
- 11 65 025 Removing and installing/renewing right exhaust turbocharger, cylinders 1-4 (S63)
- 11 65 030 Removing and installing/renewing left exhaust turbocharger, cylinders 5-8 (S63)
- 11 65 Connection diagram, vacuum activation (N63)
- 11 65 010 Removing and installing/replacing pressure accumulator (N63)
- 11 65 712 Removing and installing/replacing electric changeover valve on exhaust turbocharger, left (N63)
- 11 65 714 Removing and installing/renewing electric changeover valve on exhaust turbocharger, right (N63)
- 11 65 010 Removing and installing/replacing vacuum reservoir (N63O1)
- 11 65 010 Removing and installing/replacing vacuum reservoir (S63)
- 11 61 365 Removing and installing/replacing front left charge air duct (N55)
- 11 61 368 Removing and installing/replacing rear left charge-air duct (N55)
- 11 61 050 Removing and installing intake plenum (N55)
- 11 61 065 Removing and installing/replacing left intake plenum (N63)
- 11 61 068 Removing and installing/replacing right intake plenum (N63)
- 11 61 065 Removing and installing/replacing left intake plenum (N63O1)
- 11 61 068 Removing and installing/replacing right intake plenum (N63O1)
- 11 61 065 Removing and installing/replacing left intake plenum (S63)
- 11 61 068 Removing and installing/renewing right intake plenum (S63)
- Engine Vacuum Pump
- 11 66 521 Checking function of vacuum system (N55)
- 11 66 521 Checking function of vacuum system (S63)
- 11 66 000 Removing and installing/replacing vacuum pump (N55) - up to March 2012
- 11 66 000 Removing and installing/replacing vacuum pump (N55) - from March 2012
- 11 66 000 Remove and install or replace vacuum pump (N63)
- 11 66 000 Removing and installing or replacing vacuum pump (S63)
- EGR Valve
- Oxygen Sensors
- 11 78 510 Replacing oxygen control sensors (N55)
- 11 78 610 Replacing lambda oxygen monitoring sensor (N55)
- 11 78 530 Replacing left control sensor (N63)
- 11 78 533 Replacing right control sensor (N63)
- 11 78 540 Replacing left monitor sensor (N63)
- 11 78 543 Replacing right monitor sensor (N63)
- 11 78 530 Replacing left control sensor (N63O1)
- 11 78 533 Replacing right control sensor (N63O1)
- 11 78 540 Replacing left monitoring sensor (N63O1)
- 11 78 543 Replacing right monitoring sensor (N63O1)
- 11 78 530 Replacing left control sensor (S63)
- 11 78 533 Replacing right control sensor (S63)
- 11 78 540 Replacing left monitoring sensor (S63)
- 11 78 543 Replacing right monitoring sensor (S63)