51 71 Seals and Loose Body Parts
SEALS AND LOOSE BODY PARTS - TIGHTENING TORQUE SPECIFICATIONS (1AZ - 22AZ)
| Type | Thread | Tightening specification | Measure | |
|---|---|---|---|---|
| 1AZ Front spoiler to bumper | E36 / M3 | 3 N.m. | ||
| 2AZ Rear spoiler | E34 / Touring, E36 / Z3 Coupe / M Coupe | M6 | 6 N.m. | |
| E36 / M3 | M6 | 7 N.m. | ||
| E53 | 3 N.m. | |||
| E83 | M6 | 10 N.m. | ||
| E61 | 8 N.m. | |||
| 3AZ Reinforcement plate to front axle support/engine carrier | E46 / without AWD, E85, E86 | Replace screws | ||
| Jointing torque | 59 N.m. | |||
| Torque angle | 90 ° | |||
| 4AZ Tension strut in engine compartment | E85 / E86 | Nut | 41 N.m. | |
| Replace screw | 56 N.m. | |||
| Torque angle | 105 ±15 ° | |||
| E83 | M8 | 19 N.m. | ||
| 5AZ Reinforcing plate/ tension strut to rear axle | E85 / E46 / Convertible | M10 | Replace screws | |
| Jointing torque | 59 N.m. | |||
| Torque angle | 90 ° | |||
| 6AZ Reinforcing plate to rear axle | E85 / E86 | M8 | 21 N.m. | |
| 7AZ Tension strut to rear axle | E46 / Convertible | M8 | 24 N.m. | |
| E85, E86 | Replace nut | 24 N.m. | ||
| 8AZ Cross-member, A-pillar, to mounting | E52 | M8 | 19 N.m. | |
| 9AZ Cross-member, A-pillar, middle | E52 | M8 | 10 N.m. | |
| 10AZ Strut to cardan tunnel | E52 | M8 | 19 N.m. | |
| 11AZ Cross-member, A-pillar, bottom, to mounting | E52 | M6 | 11 N.m. | |
| 12AZ Support tube to support, steering column upper section | E65 / E66 / E67 | M8 | 21 N.m. | |
| 13AZ Support tube to body | E85 / E86 | M8 | 20 N.m. | |
| 14AZ Heater to support tube | E85 / E86 | 4 N.m. | ||
| 15AZ Support tube to body | E60 / E61 / E63 /E64 / E83 | M8 | 21 N.m. | |
| 16AZ Take-up, cover, sill to body | E83 | M8 | 5 N.m. | |
| 17AZ Cover, partition, to body, front | E61 | 2.5 N.m. | ||
| 18AZ Retaining strip, sill trim, to side panel | E61 | 5 N.m. | ||
| 19AZ Multifunction pan to body | E60 / M5 | 3 N.m. | ||
| E86 | 12 N.m. | |||
| 20AZ Underride protection to retaining bar | E60, E61 | M8 | Replace screws | 8 N.m. |
| 21AZ Retaining bar for underride protection to frame side member | E60, E61 | M8 | Replace screws | 10 N.m. |
| 22AZ Protective mat/protective cover to body | E60 / Security | M6 | Screw | 10 N.m. |