LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2003 >> 745Li >> Repair and Diagnosis >> Electrical >> Gauges >> Body Equipment - Repair Instructions >> Front Door Trim Panel With Arm Rest >> 51 41 000 Removing and installing left or right front door trim panel

51 41 000 Removing and installing left or right front door trim panel

Special tools required: 

WARNING: Side AIRBAG is mounted on door trim panel:
Disconnect battery. Refer to 12 00... INSTRUCTIONS FOR DISCONNECTING AND CONNECTING BATTERY .
IMPORTANT: Do not use any sharp-edged removal tools, risk of damage to AIRBAG.

Press on point (A) and tilt out cover.

Fig 1: Tilting Out Cover
G03290435Courtesy of BMW OF NORTH AMERICA, INC.

Release screw underneath.

Installation: 

Tightening torque 51 21 6AZ. Refer to BODY EQUIPMENT - TIGHTENING TORQUES .

IMPORTANT: Replace damaged screws and nuts.

Carefully lever caps (1) with special tool 00 9 322 out of door trim panel (2).

Fig 2: Identifying Caps
G03290436Courtesy of BMW OF NORTH AMERICA, INC.

Lever out AIRBAG emblem (1) and release screw underneath.

Fig 3: Loosening Screws
G03290437Courtesy of BMW OF NORTH AMERICA, INC.

Tightening torque 51 41 1AZ. Refer to BODY EQUIPMENT - TIGHTENING TORQUES .

Loosen screws (2).

Tightening torque 51 41 2AZ. Refer to BODY EQUIPMENT - TIGHTENING TORQUES .

Unfasten cap (3) and release screw underneath.

Tightening torque 51 41 4AZ. Refer to BODY EQUIPMENT - TIGHTENING TORQUES .

NOTE: Start unclipping at bottom.
Unclip clips (1) of door trim panel with special tool 00 9 317.
Fig 4: Removing Clips
G03290438Courtesy of BMW OF NORTH AMERICA, INC.

Carefully unclip door trim panel (1) at top from retainers (2).

Fig 5: Feeding Out Door Trim
G03290439Courtesy of BMW OF NORTH AMERICA, INC.

Feed out door trim (1) from unlocking knob (3).

Unhook Bowden cable for release lever:

Fig 6: Removing Release Lever
G03290440Courtesy of BMW OF NORTH AMERICA, INC.

Installation: 

For fitting, press release lever (1) fully onto door trim panel.

WARNING: Disconnect plug connection on side AIRBAG.

Unlock plug connection (1) and disconnect from control unit (2).

Fig 7: Disconnecting From Control Unit
G03290441Courtesy of BMW OF NORTH AMERICA, INC.

Remove door trim.

Installation: 

All clips (1) are white.

If necessary, replace faulty clips (1).

Fig 8: Installing Clips
G03290442Courtesy of BMW OF NORTH AMERICA, INC.

Installation: 

After assembling the door trim panel proceed as follows: