LEMON Manuals: Even more car manuals for everyone
Home >> BMW >> 2002 >> 325Ci 2D Convertible, Standard >> Repair and Diagnosis >> Electrical >> Gauges >> Body Equipment - Repair >> Rear Door Locks, Handles, Fittings >> 51 22 280 Removing and installing/replacing door stop on rear left or right door

51 22 280 Removing and installing/replacing door stop on rear left or right door

Raise the door window.

Disconnect battery negative lead.

NOTE: To release or partially detach sound insulation, follow procedure in "Removing and installing/replacing sound insulation on front left or right door", refer to 51 48... REMOVING AND INSTALLING/REPLACING SOUND INSULATION IN FRONT DOOR, LEFT OR RIGHT .

Partially detach sound insulation at front and secure with adhesive tape (1).

Unscrew bolt (1).

Remove seal (2) towards rear and detach from door brake (3).

Fig 1: Removing Seal Towards Rear
G03165171Courtesy of BMW OF NORTH AMERICA, INC.
NOTE: For removal, fold back screw plate (1).

Release screws (2) and feed out door brake (3) to inner door panel.

Fig 2: Feeding Out Door Brake To Inner Door Panel
G03165172Courtesy of BMW OF NORTH AMERICA, INC.

Installation: 

  1. If necessary, stick butylene tape between door stop and inner door plate.

Pull door stop (2) out of rubber sleeve (1).

Fig 3: Pulling Door Stop Out Of Rubber Sleeve
G03165173Courtesy of BMW OF NORTH AMERICA, INC.

Installation: 

  1. To install door brake (1), fold back screw plate (2) as shown in illustration.
Fig 4: Installing Door Brake, Fold Back Screw Plate
G03165174Courtesy of BMW OF NORTH AMERICA, INC.
scientia non olet · About LEMON Manuals