51 41 001 Replacing door trim panel, front left or right (Protection)

Remove door trim,

Pull wooden strip backwards to remove.

Fig 1: Pulling Wooden Strip Backwards

Courtesy of BMW OF NORTH AMERICA, INC.

Installation

Fig 2: Replacing Damaged Clips And/Or Grommets For Wooden Strip

Courtesy of BMW OF NORTH AMERICA, INC.

Release nuts (1) and remove protective mat (2) with bracket (3) from stud bolts.

Fig 3: Releasing Nuts And Remove Protective Mat With Bracket From Stud Bolts

Courtesy of BMW OF NORTH AMERICA, INC.

Speaker replacement only:

If necessary, release knurled head screw (1) and open flap (2) of protective mat.

Fig 4: Releasing Knurled Head Screw And Open Flap Of Protective Mat

Courtesy of BMW OF NORTH AMERICA, INC.

Release nuts (1) and remove speaker unit.

NOTE: Disconnect plug connection (2) to detach speaker and carrier plate.

Installation

Fig 5: Disconnecting Plug Connection To Detach Speaker And Carrier Plate

Courtesy of BMW OF NORTH AMERICA, INC.

Unfasten plastic welded joints (1) and remove loudspeaker finisher (2).

Installation

Install new loudspeaker finisher (2). Fit retaining washers (3) on the pins (4).

Fig 6: Installing New Loudspeaker Finisher And Fitting Retaining Washers On Pins

Courtesy of BMW OF NORTH AMERICA, INC.

Hi-fi speaker replacement only:

If necessary, release screws (1) and remove speaker (2).

Fig 7: Releasing Screws And Remove Speaker

Courtesy of BMW OF NORTH AMERICA, INC.

Unfasten screws (1) and lift out fresh air grille (2).

Fig 8: Unfasten Screws And Lift Out Fresh Air Grille

Courtesy of BMW OF NORTH AMERICA, INC.