Removal & Installation
Disconnect negative battery cable. Remove insulation panel below left side of dashboard. Wrap tape around headlight switch knob, and pull out headlight knob. Remove mounting nut, and pull switch out from rear. Unplug wiring, and remove switch. To install switch, reverse removal procedure.
CONTROL CHECK PANEL TROUBLE SHOOTING CHART (VOLTAGE & RESISTANCE CHECKS)
| Pin Number (Wire Color) | Function | Test Terminal (Value) |
|---|---|---|
| 1. Terminal "R" (Violet/Gray) | Ignition Key "R" | 1 (+) to 9 (-) (Battery Voltage) |
| 2. Control Warning Light (Brown/Yellow) | Ignition Key ON | 2 (+) to 9 (-) (Warning Light on Continuously) |
| 3. (Blank) | Not Used | Not Used |
| 4. Terminal "15" (Green/White) | Ignition Key ON | 4 (+) to 9 (-) (Battery Voltage) |
| 5. Oxygen (O2) Sensor (Blue/White) | Ignition Key ON | 5 (-) to 4 (+) (Battery Voltage) |
| 6. Airbag (+) | Always | 6 (+) to 9 (-) (Battery Voltage) |
| 7. Airbag (-) | Always | 7 (-) to 4 (+) (Battery Voltage) |
| 8. Seat Belt Warning (Brown/Violet) | Ignition Key ON | 8 (-) to 4 (+) (Battery Voltage) |
| 9. Terminal "31" (Brown) | Ground | 9 (-) to 15 (+) (Battery Voltage) |
| 10. (Blank) | Not Used | Not Used |
| 11. "58R" (Gray/White) | Tail Lights ON | 11 (+) to 9 (-) (Battery Voltage) |
| 12. "58L" (Gray/Yellow) | Tail Lights ON | 12 (+) to 9 (-) (Battery Voltage) |
| 13. "58KL" (Gray/Blue) | Lights ON, Bulb Test OK | 13 to 9 (-) (4.7 Ohms) |
| 14. (Blank) | Not Used | Not Used |
| 15. Terminal "30" (Red/White) | Positive From Term. "30" | 15 (+) to 9 (-) (Battery Voltage) |
| 16. Oil Level (Static) (Blue/Violet) | Level & Transmitter OK | 16 to 9 (-) (Zero Ohms) |
| 17. "W" Washer Fluid (Brown/Red) | Level & Transmitter OK | 17 to 9 (-) (Zero Ohms) |
| 18. "KW" Coolant (Brown/Blue) | Level & Transmitter OK | 18 to 9 (-) (Zero Ohms) |
| 19. (Blank) | Not Used | Not Used |
| 20. Oil Level (Dynamic) (White) | Level & Transmitter OK | 20 to 9 (-) (1 k/ohm) |
| 21. "56b" Low Beam (Yellow) | Low Beams ON | 21 (+) to 9 (-) (Battery Voltage) |
| 22. "K" Low Beam Indicator (Yellow/Black) | Low Beam & Bulb Test OK | 22 to 9 (-) (Zero Ohms) |
| 23. "54Si" Fuse Monitor (Violet/White) | Ignition Key "R" | 23 (+) to 9 (-) (Zero Ohms) |
| 24. "54KL" Stop Light Indicator (Green/Black) | Stop Lights & Bulb Test OK | 24 to 9 (-) (4.7 Ohms) |
| 25. "54" Stop Lights (Green/Red) | Brakes ON, Lights OK | 25 (+) to 9 (-) (Battery Voltage) |
| 26. "KKL" License Light Indicator (Gray/Violet) | Lights & Bulb Test OK | 26 to 9 (-) (4.7 Ohms) |