LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2023 >> e-tron Quattro Premium Plus >> Repair and Diagnosis >> Heating, Ventilation & A/C (HVAC) >> HVAC Control Systems >> Air Conditioning (Heating, Ventilation And Air Conditioning - Actuators - Air Ionization) >> 87 Air Conditioning >> Front Heater And A/C Unit >> Overview - Heater And A/C Unit Air Intake Housing

Overview - Heater And A/C Unit Air Intake Housing

The overview shows a LHD vehicle as an example. The component layout is a mirror image for RHD vehicles.

Fig 1: Exploded View Of Heater And A/C Unit Air Intake Housing
GWWA87-11811Courtesy of AUDI OF AMERICA, LLC
  1. Foam Seal
    • For sealing the fresh air intake shaft to the vehicle; bonded to the air intake duct
    • Check for damage and if necessary replace. Refer to the Parts Information.
  2. Air Intake Housing
    • With back pressure/fresh air and recirculation door
    • Do not disassemble further
  3. Lever
    • Removing and Installing. Refer to OVERVIEW - ACTUATORS ON AIR INTAKE HOUSING .
    • Apply a small amount of grease to the curved washer guides, the shaft bearings, the toothed segment as well as to the pins on the door levers. Refer to Parts Information.
  4. Fastener with Lever
    • Removing and Installing. Refer to OVERVIEW - ACTUATORS ON AIR INTAKE HOUSING .
    • Apply a small amount of grease to the curved washer guides, the shaft bearings, the toothed segment as well as to the pins on the door levers. Refer to Parts Information.
  5. Bracket
  6. Bolt
    • 1 Nm
  7. Recirculation Door Motor -V113-
  8. Dust and Pollen Filter
  9. Dust and Pollen Filter Cover
  10. Insulation
  11. Acoustic Cover
  12. Screw Clips
  13. Fresh Air Blower -V2- with Fresh Air Blower Control Module -J126-
  14. Fresh Air Door Motor -V438-
scientia non olet · About LEMON Manuals