Lock Carrier, Removing And Installing: Removing

-- Remove the impact member. Refer to IMPACT MEMBER, REMOVING AND INSTALLING .

-- Release the left and right catches with the :T10118  -arrows- and lift the upper air duct -1- slightly and remove and side air duct -2-.

Courtesy of AUDI

-- Disconnect the connector -2- for the High Pressure Sensor -G65-.

Courtesy of AUDI

-- Release the left and right catches -arrows- disengage the condenser -1- from the radiator and tie up to the side.

-- Remove the bolt -arrow-.

Courtesy of AUDI

-- Place the container of the :VAS5014  or the :VAS6208  underneath.

-- Lift the clamp -arrow- and remove the coolant hose from the lower right of the radiator and drain the coolant.

Courtesy of AUDI

-- Equipped on some models: lift up the clamp -arrow- and remove the coolant hose from the lower left side of the radiator and drain the coolant.

Courtesy of AUDI

-- Equipped on some models: lift up the clip -arrow- and remove the coolant line from the charge air cooling circuit cooler.

Courtesy of AUDI

-- Remove the coolant hoses from the coolers.

-- Disconnect the connectors -1 and 2- for the radiator fan.

Courtesy of AUDI

Vehicles with a TDI Engine:

Courtesy of AUDI

-- Vehicles with center charge air cooler: loosen the hose clamp -2-, and remove the air duct hose from the center charge air cooler -1-.

-- Seal the open lines and connections with clean plugs from the :VAS6122  .

-- Vehicles with side charge air cooler: remove the side charge air cooler. Refer to CHARGE AIR COOLER, REMOVING AND INSTALLING .

Continuation for All Vehicles:

-- Free up the hoses and wires.

-- Disconnect the latch cable at the coupling and free it up on the lock carrier. Refer to OVERVIEW - RELEASE CABLE .

-- Have a second technician hold the lock carrier -1- and remove the bolts -2 and 3-. 

Courtesy of AUDI

-- Remove the lock carrier with a second technician.

-- The following components must also be removed if the lock carrier is being replaced:

• Front upper air duct pipe on the lock carrier. Refer to OVERVIEW - CHARGE AIR SYSTEM .
• Radiator. Refer to RADIATOR, REMOVING AND INSTALLING .
• Latch. Refer to LATCH, REMOVING AND INSTALLING .
• Bracket for the lower longitudinal member. Refer to LOWER LONGITUDINAL MEMBER BRACKET, REMOVING AND INSTALLING .