Refrigerant Oil Capacities In Refrigerant Circuits For Refrigerant R1234YF

WARNING: This page is about a different variant/trim than selected.

NOTE:

The capacities for the Audi A3 (8V_ or 85_ for china) apply to all versions (Sedan, Sportback, Cabriolet, etc.)

Depending on the time period of production and the engine, the compressor construction type may vary. Refer to the Parts Information.

Depending on the A/C compressor type, different refrigerant oil capacities may be designated for the refrigerant circuit. Refer to the Parts Information.

There are different refrigerant oils used for the "Denso" -, "Delphi/Mahle" -, "Visteon" and "Sanden" A/C compressors. Refer to APPROVED REFRIGERANT OILS FOR REFRIGERANT R1234YF and the Parts Information.

For additional information about refrigerant oil. Refer to REFRIGERANT AND REFRIGERANT OIL .

Refer to APPROVED REFRIGERANT OILS FOR REFRIGERANT R1234YF
Overview and characteristics for the refrigerant circuit. Refer to SYSTEM OVERVIEW - REFRIGERANT CIRCUIT

Vehicle Model	Production Period	Total Quantity of Oil in Refrigerant Circuit in cm³	Quantity of Refrigerant Oil in Replacement Compressor in cm³	Differing Features of This Refrigerant Circuit
Audi Q2 Audi A3	From 06/2016	110 ⁺ / _- 10	110 ⁺ / _- 10	"Denso" A/C compressor
		75⁺ / _- 10	75 ⁺ / _- 10	"Sanden" A/C compressor
		110 ⁺ / _- 10	110 ⁺ / _- 10	"Delphi/Mahle" A/C compressor
Audi A3 e-tron	From 06/2016	120 ⁺ / _- 10	120 ⁺ / _- 10	Electrically-Driven A/C Compressor With second evaporator in the high-voltage battery heat exchanger Varying refrigerant oil
Audi RS 3 With 5-cylinder engine, PR number TB9	From 06/2016 through 07/2016	110 ⁺ / _- 10	110 ⁺ / _- 10	"Sanden" A/C compressors with dual belt pulleys and a condenser is installed in another version. Refer to Parts Information.
Audi RS 3 With 5-cylinder engine, PR number TM1	From 02/2017	110 ⁺ / _- 10	110 ⁺ / _- 10	"Denso" A/C compressor

NOTE:

The replacement compressor contains the full quantity of oil intended for the refrigerant circuit. If the A/C compressor is replaced, the amount of oil in the A/C compressor must then be adjusted. Refer to COMPONENTS, REPLACING .

Different A/C compressors are installed depending on the vehicle date of manufacture and the engine. Refer to the Parts Information.

These A/C compressors are available as replacement parts with different oil fill capacities, therefore note capacity on the A/C compressor and the exact part number. Refer to the Parts Information

The reason for the different oil capacities inside the A/C compressor is due to the design of the A/C compressor (with or with an oil separator on the high pressure connection) or to the design of the refrigerant circuit if the A/C compressors are have the identical design. Pay attention to the different capacities. Too much oil in the circuit leads to higher pressures and reduces cooling output of the system. Too little oil may lead to lubrication problems in the compressor.

A data plate may be attached to the A/C compressor by the manufacturer, indicating the part number and refrigerant oil quantity.