Pinpoint Test Al : DTC B19A5

WARNING: This page is about a different car, the 2017 Lincoln Navigator and 2017 Ford Expedition. However, it is still accessible from the selected car via links, so may be relevant.

NOTE: When taking measurements at Front Seat Climate Control Module (SCME) harness connectors, do not insert the electrical probes into the female connector pins. Inserting the probes into connector pins can cause intermittent or open electrical connections after reassembly resulting in Diagnostic Trouble Codes (DTCs) and system failure. Touching the tip of these connector pins is recommended instead.

NOTE: The airbag warning indicator illuminates when the correct RCM fuse is removed and the ignition is ON.

NOTE: The SRS must be fully operational and free of faults before releasing the vehicle to the customer.

AL1 CHECK CUSHION TED BLOWER SPEED CONTROL CIRCUIT FOR A SHORT TO GROUND

Ignition OFF.

Depower the SRS. Refer to SRS Depowering and Repowering in the General Procedures portion of Supplemental Restraint System .

Disconnect: Passenger Seat Side Airbag C3052.

Disconnect: Front Seat Climate Control Module (SCME) C3265C.

Disconnect: Passenger Seat Cushion TED C3040.

Measure the resistance between Front Seat Climate Control Module (SCME) C3265C-3 , circuit RHS08 (VT/WH), harness side and ground.

Courtesy of FORD MOTOR COMPANY

Is the resistance greater than 10, 000 ohms?

Yes	GO to AL2.
No	REPAIR the circuit. CLEAR the DTCs. REPEAT the self-test. DISCONNECT the battery ground cable. CONNECT passenger seat side airbag C3052. REPOWER the SRS. REFER to Supplemental Restraint System .

AL2 CHECK THE CUSHION TED BLOWER SPEED CONTROL CIRCUIT AND BLOWER GROUND CIRCUIT FOR A SHORT TOGETHER

Measure the resistance between Front Seat Climate Control Module (SCME) C3265C-3 , circuit RHS08 (VT/WH), harness side and C3265C-7 , circuit CHS08 (BN/YE), harness side.

Courtesy of FORD MOTOR COMPANY

Is the resistance greater than 10, 000 ohms?

Yes

INSTALL a new cushion TED. REFER to Seat Cushion Thermo-Electric Device . CLEAR the DTCs. REPEAT the self-test. If the DTC is retrieved again, INSTALL a new Front Seat Climate Control Module (SCME). REFER to Dual Climate Controlled Seat Module (DCSM) . CLEAR the DTCs. REPEAT the self-test. DISCONNECT the battery ground cable. CONNECT passenger seat side airbag C3052. REPOWER the SRS. REFER to Supplemental Restraint System .

REPAIR the circuits. CLEAR the DTCs. REPEAT the self-test. DISCONNECT the battery ground cable. CONNECT passenger seat side airbag C3052. REPOWER the SRS. REFER to Supplemental Restraint System .