LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2017 >> S7 Premium Plus >> Repair and Diagnosis >> Engine Mechanical >> Mechanical >> Engine System (Cylinder Head & VALVETRAIN - Service Information - 4.0L - CEUC, CRDB, CTGE, CWUB, CWUC) >> Cylinder Head, VALVETRAIN >> Chain Drive >> Camshaft Timing Chain, Removing From Camshafts >> Removing

Camshaft Timing Chain, Removing From Camshafts: Removing

NOTE:

The camshaft timing chains stay on the engine in the following description.

-- Remove the timing chain guard. Refer to TIMING CHAIN COVER, REMOVING AND INSTALLING .

Cylinder Bank 1 (Right): 

-- Remove the right drive axle from the transmission flange shaft. Refer to DRIVE AXLE .

-- Remove the bolts -arrows- and the right heat shield -1-.

GWWA10-11377

-- Remove the bolts -arrows- and remove the right drive axle heat shield.

GWWA37-10841

-- Remove the air filter.

-- Loosen the hose clamps to disconnect the hose for the EVAP canister system -1-.

GWWA20-10994

-- Free up the hose.

NOTE:

The illustration shows the Installed position on an Audi S6/S7.

Ignore item -2-.

-- Disconnect the connector -1- from the EVAP Canister Purge Regulator Valve 1 -N80-.

GWWA15-11260

-- Remove the bolt -arrow-.

-- Remove the nuts -1 and 2- and the bolt -3-, free up the guide wire and move them to the side.

GWWA15-11261

-- Remove the double bolt -arrow- and then remove the shield -1-.

GWWA15-11262
NOTE:

Do not remove ball head item -2-.

The illustration shows the Installed position on an Audi S6/S7.

Ignore items -3 and 4-.

-- Free up the turbocharger vacuum actuator hoses.

-- Disconnect the vacuum hose -1-.

GWWA21-10703

-- Disconnect the connectors -1 and 2- and push the wiring harness aside.

GWWA24-11003

-- Remove the high pressure pipe. Refer to CYLINDER BANK 1 (RIGHT) HIGH PRESSURE PIPE, REMOVING .

-- Release and remove the sealing plug from the right camshaft housing -arrows- by turning it to the left.

GWWA15-11218

Cylinder Bank 2 (Left): 

GWWA15-11219

-- Remove the ignition coil for cylinder "7". Refer to IGNITION COILS WITH POWER OUTPUT STAGES, REMOVING AND INSTALLING .

-- Release and remove the sealing plug from the left camshaft housing -arrows- by turning it to the left.

Continuation for Both Cylinder Banks: 

GWWA13-10881

Audi S6/RS6/RS7: 

-- Remove the radiator, with the fan shroud. Refer to RADIATOR, REMOVING AND INSTALLING .

Audi S7: 

-- Remove the fan shroud. Refer to FAN SHROUD, REMOVING AND INSTALLING .

Continuation for All Vehicles: 

-- Position the :T40272  onto the :T40263  .

-- Attach the adapter to the bolts on the vibration damper.

NOTE:

Ignore the notch on the :T40272  .

-- Turn the crankshaft to "TDC" in direction of engine rotation in direction of -arrow-.

NOTE:

The right camshaft housing is shown in the illustration.

If the threaded hole is not visible, turn the crankshaft one more turn.

Cylinder Bank 1 (Right): 

GWWA15-11222

-- If necessary, turn the crankshaft slightly back and forth to insert the :T40264/1  into the right cylinder head and tighten -arrows-.

Cylinder Bank 2 (Left): 

GWWA15-11221

-- If necessary, turn the crankshaft slightly back and forth to insert the :T40264/2  into the left cylinder head and tighten -arrows-.

TIP: 

Continuation for Both Cylinder Banks: 

GWWA15-11223

-- If necessary, turn the crankshaft slightly back and forth to insert the :T40264/3  by hand into the vibration damper opening and all the way into the cylinder block.

Cylinder Bank 1 (Right): 

GWWA15-11225

-- Press the right camshaft timing chain tensioner guide rails in as far as the stop using a screwdriver -1- and secure the chain tensioner with a :T40071  .

NOTE:

The toothed belt tensioner is lubricated with oil and should only be compressed slowly by applying constant pressure.

Cylinder Bank 2 (Left): 

GWWA15-11224

-- Press the left camshaft timing chain tensioner guide rails in as far as the stop using a screwdriver -1- and secure the chain tensioner with a :T40071  .

NOTE:

The toothed belt tensioner is lubricated with oil and should only be compressed slowly by applying constant pressure.

Continuation for Both Cylinder Banks: 

GWWA15-11252
CAUTION:

The camshafts can get damaged.

  • The :T40264/1  and :T40264/2  must never be used as a counterholder to loosen the camshaft adjuster bolt or camshaft chain sprocket.

-- To counterhold, attach the :T40269  to the relevant camshaft adjuster and loosen the bolt -1-.

-- Mark the installation position of the camshaft adjuster with paint for installation later.

CAUTION:

Danger of causing damage to the engine.

  • To prevent small parts from accidentally entering the engine through the opening in the timing chain compartment, cover the opening with a clean cloth.

Cylinder Bank 1 (Right): 

GWWA15-11227

-- Remove the bolts -1 and 2- and remove both of the camshaft adjusters.

-- Remove the camshaft timing chain from the gliding piece.

Cylinder Bank 2 (Left): 

GWWA15-11226

-- Remove the bolts -1 and 2- and remove both of the camshaft adjusters.

-- Remove the camshaft timing chain from the gliding piece.