LEMON Manuals: Even more car manuals for everyone
Home >> Audi >> 2016 >> S5 Prestige, 2D Convertible >> Repair and Diagnosis >> External Pages >> Different car >> Section 920 (Transmission System (Controls & Housing - Service Information - 8-Speed Automatic - 0BK AWD)) >> 37 Controls, Housing >> Transmission, Removing And Installing >> Transmission, Removing >> Transmission, Removing, Vehicles With 4.0L TFSI Engine >> Removing

Transmission, Removing, Vehicles With 4.0L TFSI Engine: Removing

WARNING: This page is about a different car, the 2018 Audi A6 Quattro, 2017 Audi A6 Quattro, and 2016 Audi A6 Quattro. However, it is still accessible from the selected car via links, so may be relevant.

-- Position the front wheels so they are straight.

CAUTION:

Risk of damaging electronic components when disconnecting the battery.

  • Complete the steps for disconnecting the battery.

-- Disconnect the battery Ground (GND) cable -2-. Refer to BATTERY .

GWWA27-10141Courtesy of AUDI OF AMERICA, LLC

-- Remove the engine cover in the direction of -arrows-.

GWWA10-11510Courtesy of AUDI OF AMERICA, LLC
WARNING:

Fire danger and danger of damaging without engine cover.

  • Before closing the front lid, the engine cover must be installed.
  • Without an engine cover with the front lid closed the vehicle must not be started and must not be driven.

-- Remove the noise insulations -1 and 2-. Refer to NOISE INSULATION .

GWWA10-11234Courtesy of AUDI OF AMERICA, LLC

-- Remove the left and right catalytic converter. Refer to CATALYTIC CONVERTER, REMOVING AND INSTALLING [For engine(s) CYNB] or CATALYTIC CONVERTER, REMOVING AND INSTALLING [For engine(s) CTGE, CEUC] orCATALYTIC CONVERTER, REMOVING AND INSTALLING [For engine(s) CREC, CREH] .

GWWA26-11198Courtesy of AUDI OF AMERICA, LLC

-- Remove the right coolant pipe on the transmission. Refer to COOLANT PIPES, REMOVING AND INSTALLING [For engine(s) CTGE, CEUC] or COOLANT PIPES, REMOVING AND INSTALLING [For engine(s) CPNB] or COOLANT PIPES, REMOVING AND INSTALLING [For engine(s) CREC, CREH] .

GWWA19-11762Courtesy of AUDI OF AMERICA, LLC

-- Remove the radiator with the fan shroud. Refer to FAN SHROUD, REMOVING AND INSTALLING [For engine(s) CTGE, CEUC] or FAN SHROUD, REMOVING AND INSTALLING [For engine(s) CPNB] or FAN SHROUD, REMOVING AND INSTALLING [For engine(s) CREC, CREH] .

GWWA19-11534Courtesy of AUDI OF AMERICA, LLC

-- Remove the driveshaft. .

GWWA39-10243Courtesy of AUDI OF AMERICA, LLC

-- Remove the ATF cooler. Refer to AUTOMATIC TRANSMISSION FLUID (ATF) COOLER, REMOVING AND INSTALLING .

-- Remove the bolts -2 through 5- connecting the engine to transmission. They are accessible from above.

GWWA34-10370Courtesy of AUDI OF AMERICA, LLC

-- Move the tower brace into its installed position and then tighten the bolts hand-tight.

GWWA37-11176Courtesy of AUDI OF AMERICA, LLC

-- Secure the engine with the :T10038  as illustrated.

-- Remove left and right drive axle cover -1- in the wheel housing. Refer to NOISE INSULATION .

GWWA10-10179Courtesy of AUDI OF AMERICA, LLC

-- Remove the bolts -arrows- and remove the left heat shield -1-.

GWWA10-11377Courtesy of AUDI OF AMERICA, LLC
NOTE:

Catch any leaking Automatic Transmission Fluid (ATF) with a cloth.

-- Remove the bolts -arrows- and remove the ATF pipe -1- from the transmission.

GWWA37-10956Courtesy of AUDI OF AMERICA, LLC

-- Seal the open lines and connections with clean plugs from the :VAS6122  .

CAUTION:

There is a risk of destroying the transmission control module (Mechatronic) with static discharge.

  • Do not touch contacts in transmission connector with hands.

-- To discharge static electricity, touch the transmission housing (without wearing gloves).

-- Turn the twist lock counter-clockwise in direction of -arrow- and disconnect the connector from the transmission.

GWWA37-10859Courtesy of AUDI OF AMERICA, LLC

-- Free up the electrical wiring harness on the transmission.

-- Remove the bolts -arrows- and then remove the heat shield from the right drive axle.

GWWA37-10841Courtesy of AUDI OF AMERICA, LLC

-- Remove the bolts -arrows- and the left drive axle heat shield.

GWWA34-10397Courtesy of AUDI OF AMERICA, LLC

-- Remove the left and right drive axles from the transmission flange shafts. Refer to DRIVE AXLE .

GWWA40-10384Courtesy of AUDI OF AMERICA, LLC

-- Remove the steering intermediate shaft from the steering gear and the push the splines together. Refer to STEERING INTERMEDIATE SHAFT, REMOVING AND INSTALLING .

GWWA48-10591Courtesy of AUDI OF AMERICA, LLC

-- Remove the bolts -arrows- and remove the heat shield.

GWWA37-11167Courtesy of AUDI OF AMERICA, LLC

-- Remove the ball socket -1- on the selector lever cable from the selector shaft lever using the :80-200  .

GWWA37-10860Courtesy of AUDI OF AMERICA, LLC

-- Press the securing clips -2- off and remove the selector lever cable from the transmission.

NOTE:

Do not bend or kink the selector lever cable.

-- Loosen the clamp -1- and remove the coolant hose.

GWWA10-11380Courtesy of AUDI OF AMERICA, LLC
NOTE:

Ignore item -2-.

-- Loosen the retainer in the direction of -arrow-, push the release downward and disconnect the connector -2- from the Power Steering Control Module -J500-.

GWWA48-10592Courtesy of AUDI OF AMERICA, LLC

-- Disconnect the connector -1- from the Power Steering Control Module -J500-.

-- Loosen the bolt -2- and remove the bolts -1 and 3-.

GWWA19-11527Courtesy of AUDI OF AMERICA, LLC
NOTE:

Ignore -arrows-.

-- Remove the lower cover -1- from the transmission in direction of -arrow-.

GWWA10-10628Courtesy of AUDI OF AMERICA, LLC

-- Attach the :T40272  to the vibration damper bolts.

GWWA37-11101Courtesy of AUDI OF AMERICA, LLC
NOTE:

Ignore the notch on the :T40272  .

-- Counterhold the crankshaft with the :T40272  and an angled wrench and loosen the drive plate bolts.

NOTE:

When mounting, turn the crankshaft only in the direction of engine rotation -arrow-.

-- Remove the six torque converter bolts -arrow- while turning the crankshaft 60° further in the direction of engine rotation.

GWWA10-10629Courtesy of AUDI OF AMERICA, LLC

-- Remove the starter bolt -1-.

GWWA34-10370Courtesy of AUDI OF AMERICA, LLC

-- Remove the starter from the transmission and leave it in the installation position.

-- Remove the remaining engine/transmission bolts -6 through 11- but leave one bolt -7- installed hand-tight.

GWWA37-10937Courtesy of AUDI OF AMERICA, LLC
CAUTION:

Danger of leaks in the Automatic Transmission Fluid (ATF) pan.

  • The :T40173  must not be set on the ATF pan.

-- Place the :VAS6031  with the prepared :T40173  on the bottom of the transmission.

-- The transmission support must be placed at the front as follows:

-- Secure the transmission with a tensioning strap -1-.

GWWA34-10670Courtesy of AUDI OF AMERICA, LLC
NOTE:

The :T40173  is not illustrated.

-- Remove the bolts from the tunnel crossmember -arrows-.

GWWA10-11281Courtesy of AUDI OF AMERICA, LLC

-- Remove the last bolt from the transmission to engine connection.

GWWA34-10670Courtesy of AUDI OF AMERICA, LLC

-- Press the transmission off the engine and lower it carefully using the :VAS6931  .