Pressure Retaining Valve, Removing And Installing: Installing

WARNING: This page is about a different car, the 2014 Volkswagen Touareg, 2013 Volkswagen Touareg, 2012 Volkswagen Touareg, and 2011 Volkswagen Touareg. However, it is still accessible from the selected car via links, so may be relevant.

Install in reverse order of removal. Note The Following:

The rear air line is covered with shrinkable tubing.

Fig 1: Shrinkable Tubing -2- Is In Contact With The Union Nut -1-.

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Insert the air line until the end of the shrinkable tubing -2- is in contact with the union nut -1-.

The end of the shrinkable tubing may be a maximum of 2 mm in front of the union nut.

-- Fill the air spring shock absorber. Refer to Vehicle Diagnostic Tester.